Chevrolet 2001 Express Van Bedienungshandbuch

viiiYou will also find a circlewith a slash through it inthis book. This safetysymbol means “Don’t,”“Don’t do this” or “Don’tlet this happen.”Vehicle

2-23Engine Coolant Heater (If Equipped)In very cold weather, 0 F (-18 C) or colder, the enginecoolant heater can help. You’ll get easier starting andb

2-244. Before starting the engine, be sure to unplug and store the cord as it was before to keep it awayfrom moving engine parts. If you don’t, it cou

2-25PARK (P): This position locks your rear wheels. It’s thebest position to use when you start your engine becauseyour vehicle can’t move easily.CAUT

2-26NEUTRAL (N): In this position, your engine doesn’tconnect with the wheels. To restart when you’re alreadymoving, use NEUTRAL (N) only. Also, useNE

2-27FIRST (1): This position gives you even more power(but lower fuel economy) than SECOND (2). You canuse it on very steep hills, or in deep snow or

2-28If the ignition is on when the parking brake is released,the brake system warning light will go off.NOTICE:Driving with the parking brake on can c

2-292. Move the shift lever into PARK (P) like this:Pull the lever toward you.Move the lever up as far as it will go.3. Move the ignition key to LOCK.

2-30Leaving Your Vehicle With the Engine RunningCAUTION:It can be dangerous to leave your vehicle with the engine running. Your vehicle could movesudd

2-31Shifting Out of PARK (P)Your vehicle has an automatic transmission shift lockcontrol system. You have to fully apply your regularbrakes before you

2-32Engine ExhaustCAUTION:Engine exhaust can kill. It contains the gascarbon monoxide (CO), which you can’t see orsmell. It can cause unconsciousness

ixFor example,these symbolsare used on anoriginal battery:CAUTIONPOSSIBLEINJURYPROTECTEYES BYSHIELDINGCAUSTICBATTERYACID COULDCAUSEBURNSAVOIDSPARKS OR

2-33CAUTION:It can be dangerous to get out of your vehicle ifthe shift lever is not fully in PARK (P) with theparking brake firmly set. Your vehicle c

2-34Tilt Wheel (Option)A tilt steering wheel allows you to adjust the steeringwheel before you drive. You can also raise it to thehighest level to giv

2-35Turn and Lane Change SignalsThe turn signal has two upward (for right) and twodownward (for left) positions. These positions allow youto signal a

2-36Windshield WipersYou control the windshieldwipers by turning the bandwith the wiper symbol on it.For a single wiping cycle, turn the band to MIST.

2-37Windshield WasherAt the top of the lever, there’s a paddle with the wordPUSH on it. To spray washer fluid on the windshield,push the paddle.CAUTIO

2-38Setting Cruise ControlCAUTION:If you leave your cruise control switch on whenyou’re not using cruise, you might hit a buttonand go into cruise whe

2-39Increasing Speed While Using Cruise ControlThere are two ways to go to a higher speed:Use the accelerator pedal to get to the higher speed.Push th

2-40Exterior LampsYour parking lamp/headlamp switch is on the driver’sside of your instrument panel.Your instrument panel dimmer thumbwheel has two de

2-41You can switch your headlamps from high to low beamby pulling on the turn signal/high beam lever.A circuit breaker protects your headlamps. If you

2-42Center High-Mounted StoplampYour vehicle’s center high-mounted stoplamp is locatedabove the rear doors at the center of the vehicle.If items are l

xModel ReferenceThis manual covers these models:Passenger VanCargo VanCab and Chassis

2-43You can use the DOME OVERRIDE button, locatedbelow the headlamp knob, to set the dome lamps toautomatically come on when a door is open, or torema

2-44MirrorsInside Day/Night Rearview MirrorPull the tab under the mirror toward you to reduce glare from headlamps behind you after dark. Push the tab

2-45Heated Outside Rearview Mirrors (If Equipped)Your outside mirrors can bedefrosted by pressing thebutton near the fan control.An indicator light on

2-46Camper-Type Mirrors (If Equipped)If your vehicle is equippedwith the camper-typemirrors, they can beadjusted so you can have aclear view of any ob

2-47Storage CompartmentsYour front storage compartment is at the center of theinstrument panel extension, by the floor. To open thecompartment, press

2-48NOTICE:Holding a cigarette lighter in with your handwhile it is heating can make it overload,damaging the lighter and the heating element.Just pus

2-49Accessory Power OutletYou can plug accessory electrical equipment into anaccessory power outlet. Just pull on the outlet cover to remove it and fo

2-50The Instrument Panel - Your Information System

2-51The main components of your instrument panel are the following:A. Lamp ControlsB. Air VentsC. Instrument Panel ClusterD. Comfort Controls SystemE.

2-52Instrument Panel ClusterUnited States version shown, Canada similarYour instrument panel cluster is designed to let you know at a glance how your

Service Station GuideOil ViscosityEngine OilSee Section 6*Engine Oil DipstickSee Section 6*Fuel See Section 6*Cooling SystemSee Section 5*Hood Release

2-53SpeedometerYour speedometer lets you see your speed in both milesper hour (mph) and kilometers per hour (km/h). Yourodometer shows how far your ve

2-54Electronic Road-Speed Governor (Gasoline Engines) (Option)This optional system automatically controls vehicle topspeed. The system controller rece

2-55Safety Belt Reminder LightWhen the key is turned to RUN or START, a tone willcome on for about eight seconds to remind people tofasten their safet

2-56CAUTION:If the air bag readiness light stays on after youstart your vehicle, it means the air bag systemmay not be working properly. The air bags

2-57VoltmeterWhen your engine is notrunning, but the ignition ison (in the RUN position),this gage shows yourbattery’s state of charge inDC volts.When

2-58United States CanadaThis light should come on briefly when you turn theignition key to RUN. If it doesn’t come on then, have it fixed so it will b

2-59Anti-Lock Brake System Warning LightWith the anti-lock brakesystem, this light will comeon when you start yourengine and may stay on for several s

2-60Malfunction Indicator Lamp (Service Engine Soon Light in the UnitedStates or Check Engine Light in Canada)(4.3L, 5.0L & 5.7L Engines and 8.1L

2-61NOTICE:Modifications made to the engine, transmission,exhaust, intake or fuel system of your vehicle orthe replacement of the original tires with

2-62If the Light Is On SteadyYou may be able to correct the emission systemmalfunction by considering the following:Did you recently put fuel into you

1-1-1Section 1 Seats and Restraint SystemsHere you’ll find information about the seats in your vehicle and how to use your safety belts properly. You

2-63Emissions Inspection and Maintenance ProgramsSome state/provincial and local governments have or may begin programs to inspect the emission contro

2-64NOTICE:If you keep driving your vehicle with this lighton, after a while, your emission controls may notwork as well, your fuel economy may not be

2-65CAUTION:Don’t keep driving if the oil pressure is low. If you do, your engine can become so hot that itcatches fire. You or others could be burned

2-66Daytime Running Lamps Indicator LightYou have this light on theinstrument panel. It willlight whenever the DRL areon. It is also a reminder toturn

2-67Fuel GageUnited States CanadaThe fuel gage, when the ignition is on, tells you abouthow much fuel you have left in your tank.The gage will first i

3-3-1Section 3 Comfort Controls and Audio SystemsIn this section, you’ll find out how to operate the comfort control and audio systems offered with yo

3-2Comfort ControlsThis section tells you how to make your air system work for you.With these systems, you can control the heating, coolingand ventila

3-3Heater/Air Conditioning Controls (If Equipped)If your vehicle has air conditioning, your heater/airconditioning controls will look like this.Before

3-4A/C: This setting is used for normal cooling on hotdays. It cools outside air and directs it through theinstrument panel outlets.BI-LEVEL A/C: This

3-5Rear Air Conditioning and Rear Heater (If Equipped)If your vehicle has a rear air conditioning and rearheater system combination, controls are prov

1-2Seats and Seat ControlsThis part tells you about the seats -- how to adjust them,take them out and put them back in. It also tells youabout reclini

3-6Rear Passenger ControlThe rear control works just like the front control. It willallow second seat passengers to adjust the controls if thefront co

3-7HeatingOn cold days, use HEAT with the temperature knob inthe red area. Outside air will be brought in through thefloor outlets. The heater works b

3-8Do not attach a temporary vehicle license, tape or decalsacross the defogger grid on the rear windows. Use carenot to damage the wiring bands that

3-9When you close a vent, it will increase the flow of aircoming out of any vents that are open.If you have rear heating or rear air conditioning, you

3-10Audio SystemsYour audio system has been designed to operate easilyand give years of listening pleasure. You will get themost enjoyment out of it i

3-11AM-FM StereoPlaying the RadioPWR VOL: Press this knob to turn the system on andoff. To increase volume, turn the knob clockwise. Turnit counterclo

3-12PUSHBUTTONS: The six numbered pushbuttons letyou return to your favorite stations. You can set up to18 stations (six AM, six FM1 and six FM2). Jus

3-13Adjusting the SpeakersBALANCE: Press and release AUDIO until BALappears on the display. Then press and hold the up arrowto move the sound to the r

3-14AM-FM Stereo with Cassette Tape Player(If Equipped)Playing the RadioPWR VOL: Press this knob to turn the system on andoff. To increase volume, tur

3-15PUSHBUTTONS: The six numbered pushbuttons letyou return to your favorite stations. You can set up to18 stations (six AM, six FM1 and six FM2). Jus

1-3Power Seat (Option)If your vehicle has a power seat on the driver’s orpassenger’s side, you can adjust it with these switcheslocated at the front c

3-16Adjusting the SpeakersBALANCE: Press and release AUDIO until BALappears on the display. Then press and hold the up arrowto move the sound to the r

3-17If the player detects a tight or broken tape, ERR (error)will appear on the display and the player will eject thetape. The radio will go back to p

3-18RPT (6): Press this button once to hear a selection overagain. RPT will appear on the display. The currentselection will continue to repeat. RPT w

3-19AM-FM Stereo with Compact Disc Player(If Equipped)Playing the RadioPWR VOL: Press this knob to turn the system on andoff. To increase volume, turn

3-20PUSHBUTTONS: The six numbered pushbuttons letyou return to your favorite stations. You can set up to 18 stations (six AM, six FM1 and six FM2). Ju

3-21Adjusting the SpeakersBALANCE: Press and release AUDIO until BALappears on the display. Then press and hold the up arrowto move the sound to the r

3-22PREV (1): Press this button or the left SEEK arrow togo to the previous track if the current selection has beenplaying for less than eight seconds

3-23Radio CalibrationYour audio system has been calibrated for your vehiclefrom the factory. If CAL appears on the display it meansthat your radio has

3-24AUTO VOL: Your system has a feature calledSpeed-Compensated Volume (SCV). With SCV, youraudio system adjusts automatically to make up for roadand

3-25P SCAN: Press and hold one of the arrows for morethan two seconds. The radio will beep once to confirm.Use P SCAN to listen to each of your favori

1-4But don’t have a seatback reclined if your vehicle is moving.CAUTION:Sitting in a reclined position when your vehicle isin motion can be dangerous.

3-26TREBLE: Press and release the P-TYPE LIST/AUDIOknob until TREB appears on the display. Turn the knobclockwise to increase treble and counterclockw

3-27FADE: Press and release the P-TYPE LIST/AUDIOknob until FADE appears on the display. Turn the knobclockwise to move the sound to the front speaker

3-28Accessing RDS Stations:1. Push the SEEK TYPE button or turn the P-TYPELIST/AUDIO knob to display the program type list.2. Turn knob either clockwi

3-29P-TYPE LIST: Turn this knob clockwise orcounterclockwise to select the Program Type (PTY) youwant to listen to. TYPE and a PTY will appear on thed

3-30While the tape is playing, use the VOL, FADE, BAL,TREB, BASS and SEEK controls just as you do for theradio. The display will show TAPE and an arro

3-31REV (3): Press this button to reverse the tape rapidly.Press it again to return to playing speed. The radio willplay the last selected station whi

3-32CLEAN: If this message appears on the display, thecassette tape player needs to be cleaned. It will still playtapes, but you should clean it as so

3-33NEXT (2): Press this button or the right SEEK arrow togo to the next track. TRACK and the track number willappear on the display. If you hold the

3-34TAPE CD: With a CD in the player and the radioplaying, press this button to play a CD. Press AM FM toreturn to the radio when a CD is playing. Pre

3-35AUTO VOL: Your system has a feature calledautomatic volume. With this feature, your audio systemadjusts automatically to make up for road and wind

1-5Rear SeatsGetting Into the Rear SeatsTo make it easier for passengers to get into the rearseats, use the fastener spot on the headliner and safetyb

3-36Setting the ToneBASS: Press the AUDIO knob until BASS appears onthe display. Turn the knob to increase or decrease bass.When you use this control,

3-37Using RDS ModeYour audio system is equipped with a Radio DataSystem (RDS). RDS mode gives you many useful newfeatures. With RDS, the radio can:See

3-38P-TYPE: This button is used to turn on and offProgram Type (PTY) select. PTY and the light next tothe button will turn on. The last selected PTY w

3-39Adjusting the SpeakersBAL-FADE: The AUDIO knob adjusts balance andfade. To adjust balance, press the AUDIO knob untilBAL appears on the display. T

3-40To insert multiple discs do the following:1. Turn the ignition on.2. Press and hold the LOAD button for two seconds.You will then hear a beep and

3-41: This button will eject a disc or discs. Do thefollowing to eject:Press and release the eject button to eject the discthat is currently playing,

3-42RDM: With random, you can listen to the tracks inrandom, rather than sequential order, on all of the discsor on one disc. To use random, do the fo

3-43Using Song List ModeThe integrated 6-disc CD changer has a feature called song list. This feature is capable of saving 20 track selections.To save

3-44To delete the entire SONG LIST:1. The disc player must be on.2. Press SONG LIST to turn song list on. S-LIST willappear on the display.3. Press an

3-45Understanding Radio ReceptionAMThe range for most AM stations is greater than for FM, especially at night. The longer range, however, cancause sta

1-62. Lift the carpet/mat flap at the inboard side of the seatbase in the rear.3. Locate the blue or yellow handle on the inboard sideof the seat base

3-46Care of Your Cassette Tape PlayerA tape player that is not cleaned regularly can causereduced sound quality, ruined cassettes or a damagedmechanis

3-47When the cleaning cassette has been ejected, the cut tapedetection feature is active again.You may also choose a non-scrubbing action, wet-typecle

3-48Fixed Mast AntennaThe fixed mast antenna can withstand most car washeswithout being damaged. If the mast should ever becomeslightly bent, you can

4-4-1Section 4 Your Driving and the RoadHere you’ll find information about driving on different kinds of roads and in varying weather conditions. We’v

4-2Defensive DrivingThe best advice anyone can give about driving is: Drive defensively.Please start with a very important safety device in yourvehicl

4-3Drunken DrivingDeath and injury associated with drinking and driving isa national tragedy. It’s the number one contributor to the highway death tol

4-4It’s the amount of alcohol that counts. For example, ifthe same person drank three double martinis (3 ouncesor 90 ml of liquor each) within an hour

4-5The body takes about an hour to rid itself of the alcoholin one drink. No amount of coffee or number of coldshowers will speed that up. “I’ll be ca

4-6Control of a VehicleYou have three systems that make your vehicle go whereyou want it to go. They are the brakes, the steering andthe accelerator.

4-7Avoid needless heavy braking. Some people drive inspurts -- heavy acceleration followed by heavy braking -- rather than keeping pace with traffic.

1-800-CHEV-USA(For vehicles purchased in Canada, call 1-800-268-6800)that provides in an emergency:1-800-CHEV-USA(For vehicles purchased in Canada, ca

1-75. Stow the locking pin on the rear of the seat base inthe hole that is provided.6. Repeat this procedure for the pin on the other seat base.7. Pul

4-8Here’s how anti-lock works. Let’s say the road is wet.You’re driving safely. Suddenly an animal jumps out infront of you.You slam on the brakes and

4-9Remember: Anti-lock doesn’t change the time you needto get your foot up to the brake pedal or always decreasestopping distance. If you get too clos

4-10Suppose you’re steering through a sharp curve. Then you suddenly accelerate. Both control systems -- steering and acceleration -- have to do their

4-11An emergency like this requires close attention and aquick decision. If you are holding the steering wheel atthe recommended 9 and 3 o’clock posit

4-12PassingThe driver of a vehicle about to pass another on atwo-lane highway waits for just the right moment,accelerates, moves around the vehicle ah

4-13Check your mirrors, glance over your shoulder andstart your left lane change signal before moving outof the right lane to pass. When you are far e

4-14A cornering skid and an acceleration skid are besthandled by easing your foot off the accelerator pedal.If your vehicle starts to slide, ease your

4-15Here are some tips on night driving.Drive defensively.Don’t drink and drive.Adjust your inside rearview mirror to reduce theglare from headlamps b

4-16Driving in Rain and on Wet RoadsRain and wet roads can mean driving trouble. On a wetroad, you can’t stop, accelerate or turn as well becauseyour

4-17Driving too fast through large water puddles or evengoing through some car washes can cause problems, too.The water may affect your brakes. Try to

1-8For the remaining rear seats, stow the safety beltlatch plate on the clip at the window trim.Replacing the Rear SeatsCAUTION:A seat that isn’t lock

4-18HydroplaningHydroplaning is dangerous. So much water can build upunder your tires that they can actually ride on the water.This can happen if the

4-19Driving Through Flowing WaterCAUTION:Flowing or rushing water creates strong forces. If you try to drive through flowing water, as youmight at a l

4-20Here are ways to increase your safety in city driving:Know the best way to get to where you are going. Get a city map and plan your trip into anun

4-21The most important advice on freeway driving is: Keepup with traffic and keep to the right. Drive at the samespeed most of the other drivers are d

4-22Before Leaving on a Long TripMake sure you’re ready. Try to be well rested. If youmust start when you’re not fresh -- such as after a day’swork --

4-23Highway HypnosisIs there actually such a condition as “highway hypnosis”?Or is it just plain falling asleep at the wheel? Call ithighway hypnosis,

4-24If you drive regularly in steep country, or if you’replanning to visit there, here are some tips that can makeyour trips safer and more enjoyable.

4-25Winter DrivingHere are some tips for winter driving:Have your vehicle in good shape for winter.You may want to put winter emergency supplies inyou

4-26Driving on Snow or IceMost of the time, those places where your tires meet theroad probably have good traction.However, if there is snow or ice be

4-27Your anti-lock brakes improve your vehicle’s stabilitywhen you make a hard stop on a slippery road. Eventhough you have an anti-lock braking syste

1-92. Position the seat into the open slots in both rails.Push the seat forward in the rail, hooking both seatbases onto the pins inside of the rails.

4-28Tie a red cloth to your vehicle to alert police thatyou’ve been stopped by the snow.Put on extra clothing or wrap a blanket around you.If you have

4-29Run your engine only as long as you must. This savesfuel. When you run the engine, make it go a little fasterthan just idle. That is, push the acc

4-30Loading Your VehicleThe Certification/Tire label is found on the rear edge ofthe driver’s door. The label shows the size of youroriginal tires and

4-31CAUTION:Things you put inside your vehicle can strike andinjure people in a sudden stop or turn, or in a crash.Put things in the cargo area of you

4-32Add-On EquipmentWhen you carry removable items, you may need to put alimit on how many people you carry inside your vehicle.Be sure to weigh your

4-33If You Do Decide To Pull A TrailerIf you do, here are some important points:There are many different laws, including speed limitrestrictions, havi

4-34Weight of the TrailerHow heavy can a trailer safely be?It depends on how you plan to use your rig. For example, speed, altitude, road grades, outs

4-35Model Engine Axle Ratio Max. Trailer Weight (lbs.) (kg)G2500 (Passenger) 5.7L 3.73 5,800 (2633)4.10 7,300 (3314)6.5L 3.73 8,100 (3677)4.10 8,100 (

4-36Maximum trailer weight is calculated assuming thedriver and one passenger are in the towing vehicle and ithas all the required trailering equipmen

4-37After you’ve loaded your trailer, weigh the trailer andthen the tongue, separately, to see if the weights areproper. If they aren’t, you may be ab

1-106. Turn the blue or yellow handle down until it is inthe retaining clip.7. Put the carpet/mat flap back in its original position.8. Repeat this pr

4-38Safety ChainsYou should always attach chains between your vehicle andyour trailer. Cross the safety chains under the tongue of thetrailer to help

4-39Driving with a TrailerCAUTION:If you have a rear-most window open and youpull a trailer with your vehicle, carbon monoxide(CO) could come into you

4-40PassingYou’ll need more passing distance up ahead whenyou’re towing a trailer. And, because you’re a good deallonger, you’ll need to go much farth

4-41Driving On GradesReduce speed and shift to a lower gear before you startdown a long or steep downgrade. If you don’t shiftdown, you might have to

4-42Maintenance When Trailer TowingYour vehicle will need service more often when you’repulling a trailer. See the Maintenance Schedule for moreon thi

5-5-1Section 5 Problems on the RoadHere you’ll find what to do about some problems that can occur on the road.5-2 Hazard Warning Flashers5-3 Other War

5-2Hazard Warning FlashersYour hazard warning flashers let you warn others. Theyalso let police know you have a problem. Your front andrear turn signa

5-3Other Warning DevicesIf you carry reflective triangles, you can use them towarn others. Set one up at the side of the road about 300 feet (100 m) b

5-41. Check the other vehicle. It must have a 12-voltbattery with a negative ground system.NOTICE:If the other system isn’t a 12-volt system with aneg

5-5NOTICE:If you leave your radio on, it could be badlydamaged. The repairs would not be covered by your warranty.4. Open the hoods and locate the bat

1-11CAUTION:It is extremely dangerous to ride in a cargo area,inside or outside of a vehicle. In a collision,people riding in these areas are more lik

5-6CAUTION:Fans or other moving engine parts can injure youbadly. Keep your hands away from moving partsonce the engine is running.5. Check that the j

5-77. Don’t let the other endtouch metal. Connect itto the positive (+)terminal of the goodbattery. Use a remotepositive (+) terminal ifthe vehicle ha

5-810. Remove the cap on the ground location before using.11. Now start the vehicle with the good battery and runthe engine for a while.12. Try to sta

5-9To disconnect the jumper cables from both vehicles, dothe following:1. Disconnect the black negative (-) cable from theheavy, unpainted metal engin

5-10If Steam Is Coming From Your EngineCAUTION:Steam from an overheated engine can burn youbadly, even if you just open the hood. Stay awayfrom the en

5-11If No Steam Is Coming From Your EngineIf you get an engine overheat warning but see or hear nosteam, the problem may not be too serious. Sometimes

5-12Cooling System (Gasoline Engine)When you decide it’s safe to lift the hood, here’s whatyou’ll see:A. Radiator Pressure CapB. Coolant Recovery Tank

5-13CAUTION:Heater and radiator hoses, and other engineparts, can be very hot. Don’t touch them. If you do, you can be burned.Don’t run the engine if

5-14How to Add Coolant to the CoolantRecovery TankIf you haven’t found a problem yet, but the coolant levelisn’t at the FULL COLD mark, add a 50/50 mi

5-15CAUTION:You can be burned if you spill coolant on hotengine parts. Coolant contains ethylene glycoland it will burn if the engine parts are hoteno

1-12Why Safety Belts WorkWhen you ride in or on anything, you go as fast as it goes.Take the simplest vehicle. Suppose it’s just a seat on wheels.Put

5-16How to Add Coolant to the Radiator1. You can remove the radiator pressure cap when thecooling system, including the radiator pressure capand upper

5-173. Fill the radiator with the proper DEX-COOLcoolant mixture, up to the base of the filler neck. See“Engine Coolant” in the Index for more informa

5-186. Start the engine and let it run until you can feel theupper radiator hose getting hot. Watch out for theengine cooling fan.7. By this time, the

5-19Engine Fan NoiseYour vehicle has a clutched engine cooling fan. Whenthe clutch is engaged, the fan spins faster to providemore air to cool the eng

5-20Changing a Flat TireIf a tire goes flat, avoid further tire and wheel damageby driving slowly to a level place. Turn on your hazardwarning flasher

5-21Removing the Spare Tire and ToolsYour spare tire is stored underneath the rear of yourvehicle. You will use the ratchet and extension to lowerthe

5-22For vans with the 15-passenger seating arrangement, the jack is secured on the rear passenger side floor of the vehicle.Remove the retaining wing

5-23Turn the ratchet counterclockwise to lower the spare tireto the ground. If you are changing a flat rear tire and thevehicle is already jacked up,

5-24Jacking Tool StorageA. SocketB. Jack HandleC. RatchetD. Jacking Tool Storage BoxE. Jack Handle ExtensionThe tools you’ll be using include the jack

5-25Removing the Wheel Covers and LockingWheel Nuts1. You will need to take off the wheel nut caps to reachyour wheel nuts. When using the ratchet and

1-13Get it up to speed. Then stop the vehicle. The riderdoesn’t stop.The person keeps going until stopped by something.In a real vehicle, it could be

5-263. Remove the center cap.Removing the Flat Tire and Installing theSpare Tire1. With the DOWN side facing you, use the ratchet andsocket to loosen

5-272. The jack has a bolt on the end. Attach the socket endof the extension to the jack bolt.Attach the ratchet to the extension with the UP sidefaci

5-284. Position jack under the vehicleas shown. Rear PositionCAUTION:Getting under a vehicle when it is jacked up isdangerous. If the vehicle slips of

5-295. Raise the vehicle by turning the ratchet clockwise.Make sure the UP mark faces you. Raise the vehiclefar enough off the ground so there is enou

5-30CAUTION:Rust or dirt on the wheel, or on the parts towhich it is fastened, can make the wheel nutsbecome loose after a time. The wheel could comeo

5-3110. Tighten the nuts firmly in a crisscrosssequence asshown. Turn the wheel wrench clockwise.CAUTION:Incorrect wheel nuts or improperly tightenedw

5-32Storing a Flat or Spare Tire and ToolsCAUTION:Storing a jack, a tire or other equipment in thepassenger compartment of the vehicle couldcause inju

5-333. Pull the wheel toward the rear of the vehicle,keeping the cable tight.4. Attach the ratchet, with the UP side facing you, tothe extension.

5-345. Put the flat end of the extension on an angle throughthe hole in the rear door frame, above the bumper.6. Raise the tire fully against the unde

5-35If You’re Stuck: In Sand, Mud, Ice or SnowIn order to free your vehicle when it is stuck, you willneed to spin the wheels, but you don’t want to s

1-14or the instrument panel ... or the safety belts!With safety belts, you slow down as the vehicle does.You get more time to stop. You stop over more

6-6-1Section 6 Service and Appearance CareHere you will find information about the care of your vehicle. This section begins with service and fuel inf

6-2ServiceYour dealer knows your vehicle best and wants you tobe happy with it. We hope you’ll go to your dealer forall your service needs. You’ll get

6-3CAUTION:You can be injured and your vehicle could bedamaged if you try to do service work on avehicle without knowing enough about it.Be sure you h

6-4In Canada, look for the“Auto Makers’ Choice”label on the fuel pump.Canada OnlyBe sure the posted octane is at least 87. If the octane isless than 8

6-5To provide cleaner air, all gasolines in the United Statesare now required to contain additives that will helpprevent deposits from forming in your

6-6If your vehicle has a diesel engine, see “Filling YourTank (Diesel Engine)” in the Diesel Engine Supplement.The fuel cap is behind ahinged door on

6-7When you put the cap back on, turn it to the right (clockwise) until you hear a clicking sound. Makesure you fully install the cap. The diagnostic

6-8Checking Things Under the HoodCAUTION:If your vehicle has air conditioning, the auxiliaryengine fan under the hood can start up andinjure you even

6-9Then go to the front of the vehicle and release thesecondary hood release.Lift the hood, release thehood prop from its retainerand put the hood pro

6-10Engine Compartment OverviewWhen you lift the hood, you’ll see these items:A. BatteryB. Coolant Recovery TankC. Engine Oil DipstickD. Engine Oil Fi

1-15Here Are Questions Many People AskAbout Safety Belts -- and the AnswersQ:Won’t I be trapped in the vehicle after anaccident if I’m wearing a safet

6-11Before closing the hood, be sure all the filler caps are on properly.Then lift the hood to relieve pressure on the hood prop.Remove the hood prop

6-12Engine:Removal or rendering engine speed governor (if equipped) inoperative so as to allow engine speedto exceed manufacturer specifications.Fan a

6-13Turn off the engine and give the oil several minutes todrain back into the oil pan. If you don’t, the oil dipstickmight not show the actual level.

6-14What Kind of Engine Oil to UseOils recommended for your vehicle can be identified bylooking for the starburst symbol.This symbol indicates that th

6-15As in the chart shown previously, SAE 5W-30 is best foryour vehicle. However, you can use SAE 10W-30 if it’sgoing to be 0 F (-18 C) or above. Thes

6-16If none of them is true, use the long trip/highwaymaintenance schedule. Change the oil and filter every7,500 miles (12 500 km) or 12 months -- whi

6-17The engine air cleaner/filter is located near the center of the engine compartment. See “Engine Compartment Overview” in the Index for moreinforma

6-18CAUTION:Operating the engine with the air cleaner/filteroff can cause you or others to be burned. The aircleaner not only cleans the air, it stops

6-19How to CheckBecause this operation can be a little difficult, you may choose to have this done at the dealershipservice department.If you do it yo

6-20Checking the Fluid LevelPrepare your vehicle as follows:Park your vehicle on a level place. Keep the engine running.With the parking brake applied

1-16How to Wear Safety Belts ProperlyAdultsThis part is only for people of adult size.Be aware that there are special things to know aboutsafety belts

6-213. Check both sides of the dipstick, and read the lowerlevel. The fluid level must be in the COLD area,below the cross-hatched area, for a cold ch

6-22Rear AxleWhen to Check and Change LubricantRefer to the Maintenance Schedule to determine howoften to check the lubricant and when to change it. S

6-23NOTICE:When adding coolant, it is important that you use only DEX-COOL (silicate-free) coolant.If coolant other than DEX-COOL is added to the sys

6-24NOTICE:If you use an improper coolant mixture, yourengine could overheat and be badly damaged.The repair cost wouldn’t be covered by yourwarranty.

6-25Adding CoolantIf you need more coolant, add the proper DEX-COOLcoolant mixture at the coolant recovery tank.CAUTION:Turning the radiator pressure

6-26Radiator Pressure CapThe radiator pressurecap is located near the center of theengine compartment.NOTICE:Your radiator cap is a pressure-type cap

6-27When to Check Power Steering FluidIt is not necessary to regularly check power steeringfluid unless you suspect there is a leak in the system oryo

6-28NOTICE:When using concentrated washer fluid,follow the manufacturer’s instructions foradding water.Don’t mix water with ready-to-use washerfluid.

6-29The other reason is that fluid is leaking out of the brakesystem. If it is, you should have your brake systemfixed, since a leak means that sooner

6-30What to AddWhen you do need brake fluid, use only DOT-3 brakefluid. Refer to “Recommended Fluids and Lubricants”in the Index. Use new brake fluid

2001 Chevrolet ExpressOwner's ManualLitho in U.S.A.Part Number C2114 A First Edition© Copyright General Motors Corporation 2000All Rights Reserv

1-175. To make the lap part tight, pull down on the buckleend of the belt as you pull up on the shoulder belt.The lap part of the belt should be worn

6-31Brake WearYour vehicle has front disc brakes and rear drum brakes.Disc brake pads have built-in wear indicators that make ahigh-pitched warning so

6-32Brake AdjustmentEvery time you make a brake stop, your disc brakesadjust for wear.If your brake pedal goes down farther than normal, yourrear drum

6-33Vehicle StorageIf you’re not going to drive your vehicle for 25 days or more, remove the black, negative (-) cable from the battery. This will hel

6-34Sealed Beam Headlamp1. Remove the four screws from the headlamp retainer.Pull the retainer out and set it aside.2. Unplug the lamp assembly from t

6-355. Reinstall the new bulb into the socket and return it tothe headlamp assembly.Front Parking/Turn Signal LampsTo replace the front parking/turn s

6-362. Remove the lamp from the grille.3. Squeeze the tab on the side of the bulb assemblywhile turning it counterclockwise.4. Remove the bulb assembl

6-372. Unclip the bottom of the lamp from the grille.3. Pull the bulb straight out to remove it. Install the new bulb.4. Reverse these steps to reinst

6-383. Remove the nuts with a deep socket wrench. 4. Remove the hidden upper nuts.

6-395. Lift the lamp as you turn it toward the rear of the vehicle.6. Squeeze the tab on the side of the sockets whileturning them counterclockwise.

6-407. Turn the old bulb counterclockwise to remove it.Install the new bulb.8. Reverse the above steps to reinstall the lamp.Windshield Wiper Blade Re

1-18Shoulder Belt Height AdjusterBefore you begin to drive, move the shoulder beltadjuster to the height that is right for you.To move it down, push i

6-412. Press down on the blade assembly pivot locking tab.Pull down on the blade assembly to release it fromthe wiper arm hook.3. The insert has two n

6-42Inflation -- Tire PressureThe Certification/Tire label, which is on the rear edge ofthe driver’s door, shows the correct inflation pressuresfor yo

6-43Tire Inspection and RotationTires should be rotated every 6,000 to 8,000 miles (10 000 to 13 000 km). Any time you notice unusualwear, rotate your

6-44If your vehicle has dual rear wheels, always use one ofthe correct rotation patterns shown here when rotatingyour tires.When you install dual whee

6-45When It’s Time for New TiresOne way to tell when it’stime for new tires is tocheck the treadwearindicators, which willappear when your tires haveo

6-46Buying New TiresTo find out what kind and size of tires you need, look atthe Certification/Tire label.The tires installed on your vehicle when it

6-47Uniform Tire Quality GradingQuality grades can be found where applicable on the tiresidewall between tread shoulder and maximum sectionwidth. For

6-48Temperature -- A, B, CThe temperature grades are A (the highest), B, and C,representing the tire’s resistance to the generation ofheat and its abi

6-49CAUTION:Using the wrong replacement wheels, wheel boltsor wheel nuts on your vehicle can be dangerous.It could affect the braking and handling of

6-50Tire ChainsNOTICE:Use tire chains only where legal and only whenyou must. Use chains that are the proper size for your tires. Install them on the

1-19Q: What’s wrong with this?A: The shoulder belt is too loose. It won’t give nearlyas much protection this way.CAUTION:You can be seriously hurt if

6-51Don’t use any of these unless this manual says you can.In many uses, these will damage your vehicle:AlcoholLaundry SoapBleachReducing AgentsCleani

6-52Special Fabric Cleaning ProblemsStains caused by such things as catsup, coffee (black),egg, fruit, fruit juice, milk, soft drinks, vomit, urine an

6-53Cleaning the Top of the Instrument PanelUse only mild soap and water to clean the top surfacesof the instrument panel. Sprays containing silicones

6-54Grime from the windshield will stick to the wiper blades and affect their performance. Clean the blade bywiping vigorously with a cloth soaked in

6-55Finish CareOccasional waxing or mild polishing of your vehicle byhand may be necessary to remove residue from the paintfinish. You can get GM-appr

6-56Cleaning Aluminum Wheels (If Equipped)Keep your wheels clean using a soft clean cloth withmild soap and water. Rinse with clean water. Afterrinsin

6-57Finish DamageAny stone chips, fractures or deep scratches in the finishshould be repaired right away. Bare metal will corrodequickly and may devel

6-58GM Vehicle Care/Appearance MaterialsPART NUMBER SIZE DESCRIPTION USAGE994954 23 in. x 25 in. Polishing Cloth – Wax Treated Exterior polishing clot

6-59Vehicle Identification Number (VIN)This is the legal identifier for your vehicle. It appears ona plate in the front corner of the instrument panel

6-60Electrical SystemAdd-On Electrical EquipmentNOTICE:Don’t add anything electrical to your vehicleunless you check with your dealer first. Someelect

1-20Q: What’s wrong with this?A: The belt is buckled in the wrong place.CAUTION:You can be seriously injured if your belt isbuckled in the wrong place

6-61Instrument Panel Fuse BlockThe fuse block access dooris on the driver’s side of theinstrument panel above thehood release lever.You can remove the

6-62POSITION NAME CIRCUITS PROTECTED1. STOP CHMSL, Stoplamps2. HTD MIR Electric Heated Mirrors3. CTSY Courtesy Lamps, Dome/RDG Lamps, Vanity Mirrors,

6-63POSITION NAME CIRCUITS PROTECTED15. DRL DRL Relay16. TURN B/UFront Turn, RR Turn, Back-up Lamps, BTSI Solenoid17.RADIO-1Radio (Ign, Accy), Upfitte

6-64Engine Compartment Fuse Relay CenterThe fuse block is on the driver’s side of the enginecompartment at the rear.NAME CIRCUITS PROTECTEDSPARE Spare

6-65NAME CIRCUITS PROTECTEDETC Electronic Throttle ControlRR BLOWER Rear Auxiliary Blower Motor RelaysFUEL SOL Fuel SolenoidENG-I Heated O2 Sensors, M

6-66Replacement BulbsLAMP OR BULB QTY NUMBERSealed Beam Headlamps 2 H6054Composite Low-Beam Headlamps2 6052Composite High-BeamHeadlamps2 9005Front Sid

6-67Capacities and SpecificationsAll capacities are approximate. When adding, be sure to fill to the appropriate level or as recommended in this manua

6-68Wheel Nut TorqueMODEL TORQUEAll140 lb-ft (190 N·m)Cooling System CapacityENGINE VIN QTY Without Rear Heater QTY With Rear Heater“VORTEC” 4300 V6

6-69Crankcase CapacityENGINE VIN Quantity With Filter“VORTEC” 4300 V6 W 4.5 quarts (4.3 L)“VORTEC” 5000 V8 M 5.0 quarts (4.8 L)“VORTEC” 5700 V8 R 5.0

6-70Normal Maintenance Replacement PartsReplacement PartsReplacement part numbers listed in this section are based on the latest information available

1-21Q: What’s wrong with this?A: The belt is over an armrest.CAUTION:You can be seriously injured if your belt goesover an armrest like this. The belt

7-7-1Section 7 Maintenance ScheduleThis section covers the maintenance required for your vehicle. Your vehicle needs these services to retain its safe

7-2Have you purchased the GM Protection Plan? The Plansupplements your new vehicle warranties. See yourWarranty and Owner Assistance booklet or your d

7-3How This Section is OrganizedThis maintenance schedule is divided into five parts:“Part A: Scheduled Maintenance Services” showswhat to have done a

7-4Part A: Scheduled Maintenance ServicesUsing Your Maintenance ScheduleWe at General Motors want to help you keep yourvehicle in good working conditi

Scheduled Maintenance7-5Short Trip/City DefinitionFollow the Short Trip/City Scheduled Maintenance ifany one of these conditions is true for your vehi

Scheduled Maintenance7-6Short Trip/City IntervalsEvery 24,000 Miles (40 000 km): Diesel Engine Only:Fuel Cap Replacement, if driving in dusty conditio

Scheduled Maintenance7-7Long Trip/Highway DefinitionFollow this scheduled maintenance only if none of theconditions from the Short Trip/City Scheduled

Scheduled Maintenance7-8Long Trip/Highway IntervalsEvery 50,000 Miles (83 000 km): AutomaticTransmission Service (vehicles over 8600 GVWR or driven un

Short Trip/City Scheduled Maintenance7-9The services shown in this schedule up to 100,000 miles(166 000 km) should be performed after 100,000 miles(16

Short Trip/City Scheduled Maintenance7-103,000 Miles (5 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission C

1-22Q: What’s wrong with this?A: The shoulder belt is worn under the arm. It shouldbe worn over the shoulder at all times.CAUTION:You can be seriously

Short Trip/City Scheduled Maintenance7-1112,000 Miles (20 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-1215,000 Miles (25 000 km) (Continued)Clean and repack the front wheel bearings (or at each brake relining,whic

Short Trip/City Scheduled Maintenance7-1318,000 Miles (30 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-1424,000 Miles (40 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-1530,000 Miles (50 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-1630,000 Miles (50 000 km) (Continued)Rotate tires. See “Tire Inspection and Rotation” in the Index for properr

Short Trip/City Scheduled Maintenance7-1736,000 Miles (60 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-1842,000 Miles (70 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-19Vehicles With GVWR Above 10,000 lbs. or Equipped with Diesel EngineOnly: Inspect shields for damage or loosen

Short Trip/City Scheduled Maintenance7-2048,000 Miles (80 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

1-23Q: What’s wrong with this?A: The belt is twisted across the body.CAUTION:You can be seriously injured by a twisted belt. Ina crash, you wouldn’t h

Short Trip/City Scheduled Maintenance7-2151,000 Miles (85 000 km)Change engine oil and filter (or every 3 months, whichever occurs first).An Emission

Short Trip/City Scheduled Maintenance7-2260,000 Miles (100 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-23Gasoline Engine Only: Conduct evaporative control system inspection. Checkall fuel and vapor lines and hoses

Short Trip/City Scheduled Maintenance7-2463,000 Miles (105 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-2572,000 Miles (120 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-2675,000 Miles (125 000 km) (Continued)Diesel Engine Only: Inspect engine air cleaner filter if you are driving

Short Trip/City Scheduled Maintenance7-2778,000 Miles (130 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-2887,000 Miles (145 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-29Rotate tires. See “Tire Inspection and Rotation” in the Index for properrotation pattern and additional infor

Short Trip/City Scheduled Maintenance7-3093,000 Miles (155 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

1-24To unlatch the belt, just push the button on the buckle.The belt should go back out of the way.Before you close the door, be sure the belt is out

Short Trip/City Scheduled Maintenance7-3199,000 Miles (165 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-32100,000 Miles (166 000 km) (Continued)If you haven’t used your vehicle under severe service conditions listed

Long Trip/Highway Scheduled Maintenance7-33The services shown in this schedule up to 100,000 miles(166 000 km) should be performed after 100,000 miles

Long Trip/Highway Scheduled Maintenance7-347,500 Miles (12 500 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emissi

Long Trip/Highway Scheduled Maintenance7-35Rotate tires. See “Tire Inspection and Rotation” in the Index for properrotation pattern and additional inf

Long Trip/Highway Scheduled Maintenance7-3630,000 Miles (50 000 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emiss

Long Trip/Highway Scheduled Maintenance7-37Diesel Engine Only: Check the air intake system installation to assure thatgaskets are properly sealed and

Long Trip/Highway Scheduled Maintenance7-3845,000 Miles (75 000 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emiss

Long Trip/Highway Scheduled Maintenance7-3950,000 Miles (83 000 km)Change automatic transmission fluid and filter if the vehicle has a dieselengine, i

Long Trip/Highway Scheduled Maintenance7-4060,000 Miles (100 000 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emis

1-25The best way to protect the fetus is to protect themother. When a safety belt is worn properly, it’s morelikely that the fetus won’t be hurt in a

Long Trip/Highway Scheduled Maintenance7-41If Equipped: Inspect Exhaust Gas Recirculation (EGR) system as described in the service manual. An Emission

Long Trip/Highway Scheduled Maintenance7-4267,500 Miles (112 500 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emis

Long Trip/Highway Scheduled Maintenance7-43Rotate tires. See “Tire Inspection and Rotation” in the Index for properrotation pattern and additional inf

Long Trip/Highway Scheduled Maintenance7-4490,000 Miles (150 000 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emis

Long Trip/Highway Scheduled Maintenance7-45Diesel Engine Only: Check the air intake system installation to assure thatgaskets are properly sealed and

Long Trip/Highway Scheduled Maintenance7-46100,000 Miles (166 000 km)Gasoline Engine Only: Inspect spark plug wires. An Emission Control Service.Gasol

Long Trip/Highway Scheduled Maintenance7-47150,000 Miles (240 000 km)Drain, flush and refill cooling system (or every 60 months since last service,whi

7-48Part B: Owner Checks and ServicesListed in this part are owner checks and services whichshould be performed at the intervals specified to helpensu

7-49At Least Twice a YearRestraint System CheckMake sure the safety belt reminder light and all yourbelts, buckles, latch plates, retractors and ancho

7-50At Least Once a YearKey Lock Cylinders ServiceLubricate the key lock cylinders with the lubricantspecified in Part D.Body Lubrication ServiceLubri

1-26If it says AIR BAG on the middle part of the steeringwheel and AIR BAG on the instrument panel in front ofthe right front passenger’s seat, your v

7-51Automatic Transmission Shift Lock Control System CheckCAUTION:When you are doing this check, the vehicle couldmove suddenly. If it does, you or ot

7-52Parking Brake and Automatic TransmissionPARK (P) Mechanism CheckCAUTION:When you are doing this check, your vehiclecould begin to move. You or oth

7-53Part C: Periodic Maintenance InspectionsListed in this part are inspections and services whichshould be performed at least twice a year (for insta

7-54Throttle System Inspection (Gasoline Engine)Inspect the throttle system for interference or binding,and for damaged or missing parts. Replace part

7-55Part D: Recommended Fluids and LubricantsNOTE: Fluids and lubricants identified below by name,part number or specification may be obtained from yo

7-56USAGE FLUID/LUBRICANTHydraulic Brake SystemDelco Supreme 11 Brake Fluid(GM Part No. 12377967 orequivalent DOT-3 brake fluid).WindshieldWasher Sol

7-57USAGE FLUID/LUBRICANTRear Axle(LockingDifferential)Axle Lubricant; use only GM Part No. 1052271. Do not addfriction modifier.PropshaftSplines andU

7-58Part E: Maintenance RecordAfter the scheduled services are performed, record the date, odometer reading and who performed the service in theboxes

7-59Maintenance RecordDATEODOMETERREADINGSERVICED BY MAINTENANCE PERFORMED

7-60Maintenance RecordDATEODOMETERREADINGSERVICED BY MAINTENANCE PERFORMED

iiTable of ContentsWindowsKeys and Door LocksKeyless Entry System (If Equipped)Automatic TransmissionParking Brake Tilt Wheel (Option)Turn Signal/Mult

1-27Here are the most important things to know about the air bag system:CAUTION:You can be severely injured or killed in a crash ifyou aren’t wearing

8-8-1Section 8 Customer Assistance InformationHere you will find out how to contact Chevrolet if you need assistance. This section also tells you how

8-2Customer Satisfaction ProcedureYour satisfaction and goodwill are important to yourdealer and to Chevrolet. Normally, any concerns withthe sales tr

8-3STEP TWO -- If after contacting a member of dealership management, it appears your concern cannot beresolved by the dealership without further help

8-4The BBB Auto Line Program is an out of court programadministered by the Council of Better Business Bureaus to settle automotive disputes regarding

8-5From:Puerto Rico: 1-800-496-9992 (English)1-800-496-9993 (Spanish)U.S. Virgin Islands: 1-800-496-9994313-381-0022 (Fax Number)CanadaGeneral Motor

8-6Chevrolet Roadside Assistance ProgramTo enhance Chevrolet’s strong commitment to customersatisfaction, Chevrolet is excited to announce theestablis

8-7Chevrolet offers Courtesy Transportation for customersneeding warranty service. Courtesy Transportation willbe offered in conjunction with the cove

8-8Courtesy TransportationChevrolet has always exemplified quality and value in its offering of motor vehicles. To enhance yourownership experience, w

8-9Courtesy Rental VehicleWhen your vehicle is unavailable due to overnightwarranty repairs, your dealer may arrange to provideyou with a courtesy ren

8-10REPORTING SAFETY DEFECTSTO THE UNITED STATESGOVERNMENTIf you believe that your vehicle has a defect which couldcause a crash or could cause injury

1-28If your vehicle has an air bag for the right frontpassenger, please read this:CAUTION:Anyone who is up against, or very close to, anyair bag when

8-11REPORTING SAFETY DEFECTSTO GENERAL MOTORSIn addition to notifying NHTSA (or Transport Canada)in a situation like this, we certainly hope you’ll no

8-122001 CHEVROLET SERVICE PUBLICATIONS ORDERING INFORMATIONThe following publications covering the operation and servicing of your vehicle can be pur

8-13PUBLICATION FORMNUMBEROrders will be mailed within 10 days of receipt. Please allow adequate time for postalservice. If further information is nee

1-29How the Air Bag System WorksWhere are the air bags?The driver’s air bag is in the middle of the steering wheel.The right front passenger’s air bag

1-30CAUTION:If something is between an occupant and an airbag, the bag might not inflate properly or itmight force the object into that person. The pa

1-31How does an air bag restrain?In moderate to severe frontal or near-frontal collisions,even belted occupants can contact the steering wheel or thei

1-32Your vehicle is equipped with a crash sensing anddiagnostic module, which records information aboutthe air bag system. The module records informat

1-33Adding Equipment to Your AirBag-Equipped VehicleQ: If I add a push bumper or a bicycle rack to thefront of my vehicle, will it keep the air bagsfr

1-34Rear Seat PassengersIt’s very important for rear seat passengers to buckle up!Accident statistics show that unbelted people in the rearseat are hu

1-35Lap-Shoulder BeltThe positions next to the windows have lap-shoulderbelts. Here’s how to wear one properly.1. Pick up the latch plate and pull the

1-363. To make the lap part tight, pull down on the buckleend of the belt as you pull up on the shoulder part.The lap part of the belt should be worn

iiiSection 3Comfort Controls and Audio SystemsSection 4Your Driving and the RoadSection 5Table of Contents (cont'd)Your Driving, the Road and

1-37CAUTION:You can be seriously hurt if your shoulder belt istoo loose. In a crash, you would move forwardtoo much, which could increase injury. Thes

1-38Rear Safety Belt Comfort Guides forChildren and Small AdultsYour vehicle may have rear shoulder belt comfortguides. This feature will provide adde

1-392. Slide the guide under and past the belt. The elasticcord must be under the belt. Then, place the guideover the belt, and insert the two edges o

1-404. Buckle, position and release the safety belt asdescribed in “Rear Seat Outside Passenger Positions”earlier in this section. Make sure that the

1-41Lap BeltIf your vehicle has rear bench seats, someone can sit inthe center positions.When you sit in a center seating position, you have a lapsafe

1-42ChildrenEveryone in a vehicle needs protection! This includesinfants and all other children. Neither the distancetraveled nor the age and size of

1-43CAUTION:People should never hold a baby in their armswhile riding in a vehicle. A baby doesn’t weighmuch -- until a crash. During a crash a baby w

1-44CAUTION:Children who are up against, or very close to, anyair bag when it inflates can be seriously injuredor killed. Air bags plus lap-shoulder b

1-45CAUTION:Newborn infants need complete support,including support for the head and neck. This isnecessary because a newborn infant’s neck isweak and

1-46Infants and Young Children (Cargo Vans with Passenger Air Bags)CAUTION:Children who are up against, or very close to, anyair bag when it inflates

ivFuelChecking Fluids and LubricantsEngine Air Cleaner/FilterBrakesBulb ReplacementWindshield Wiper Blade ReplacementTires and WheelsAppearance CareEl

1-47CAUTION:People should never hold a baby in their armswhile riding in a vehicle. A baby doesn’t weighmuch -- until a crash. During a crash a baby w

1-48Restraint Systems for ChildrenAn infant car bed (A), a special bed made for use in amotor vehicle, is an infant restraint system designed torestra

1-49A forward-facing child seat (C-E) provides restraint forthe child’s body with the harness and also sometimeswith surfaces such as T-shaped or shel

1-50Q: How do child restraints work?A: A child restraint system is any device designed foruse in a motor vehicle to restrain, seat, or positionchildre

1-51Where to Put the Restraint (Except CargoVans and Cab and Chassis Models)Accident statistics show that children are safer if theyare restrained in

1-52Where to Put the Restraint (Cargo Vansand Cab and Chassis Models)The child restraint must be secured properly in thepassenger seat. If your vehicl

1-53In Canada, the law requires that forward-facing childrestraints have a top strap, and that the strap beanchored. In the United States, some child

1-54Anchor the top strap to this bracket. For the leftoutboard seating position, use anchor point (A). For theright outboard seating position, use anc

1-55If the shoulder belt goes in front of the child’s face orneck, put it behind the child restraint.3. Buckle the belt. Make sure the release button

1-565. To tighten the belt, feed the shoulder belt back intothe retractor while you push down on the childrestraint. If you’re using a forward-facing

vTable of Contents (cont'd)Customer Assistance InformationIn the Index you will find an alphabetical listing of almost every subject in this manu

1-571. Make the belt as long as possible by tilting the latchplate and pulling it along the belt.2. Put the restraint on the seat.3. Run the vehicle’s

1-58To remove the child restraint, just unbuckle the vehicle’ssafety belt. It will be ready to work for an adult or largerchild passenger.Securing a C

1-59You’ll be using the lap-shoulder belt. See the earlier partabout the top strap if the child restraint has one. Be sureto follow the instructions t

1-605. Pull the rest of the shoulder belt all the way out ofthe retractor to set the lock.6. To tighten the belt, feed the shoulder belt back into the

1-61Older ChildrenOlder children who have outgrown booster seats shouldwear the vehicle’s safety belts.If you have the choice, a child should sit next

1-62CAUTION:Never do this.Here two children are wearing the same belt. Thebelt can’t properly spread the impact forces. In acrash, the two children ca

1-63CAUTION:Never do this.Here a child is sitting in a seat that has alap-shoulder belt, but the shoulder part is behindthe child. If the child wears

1-64Safety Belt ExtenderIf the vehicle’s safety belt will fasten around you, youshould use it.But if a safety belt isn’t long enough to fasten, yourde

2-2-1Section 2 Features and ControlsHere you can learn about the many standard and optional features on your vehicle, and information on starting,shif

2-2WindowsCAUTION:Leaving children in a vehicle with the windowsclosed is dangerous. A child can be overcome bythe extreme heat and can suffer permane

viGENERAL MOTORS, GM, the GM Emblem,CHEVROLET, the CHEVROLET Emblem and thename EXPRESS are registered trademarks of GeneralMotors Corporation.This ma

2-3Manual WindowsTo operate your manual windows, turn the hand crankon each door to raise or lower your side door windows.Power Windows (Option)If you

2-4Swing-Out WindowsSide Swing-Out WindowTo open the side door swing-out windows, pull up onthe latch at the edge of the window. Swing the windowout a

2-5CAUTION:It can be dangerous to drive with the rear door(s)or rear swing-out windows open because carbonmonoxide (CO) gas can come into your vehicle

2-6Your vehicle has onedouble-sided key for theignition and all door locks.If you ever lose your key, your dealer will be able toassist you with obtai

2-7There are several ways to lock and unlock your vehicle.If your vehicle is equipped with keyless entry, see“Keyless Entry System” later in this sect

2-8Rear Door Security LockSecurity locks are located on the passenger side reardoor, the side sliding door or the front portion of the 60/40 side swin

2-9Keyless Entry System (If Equipped)If your vehicle has this feature, you can lock and unlockyour doors from about 3 feet (1 m) up to 30 feet (9 m)aw

2-10OperationTo unlock the driver’s door, press the UNLOCK button.If you press this button again within five seconds, all ofthe doors will unlock. Pre

2-11NOTICE:When replacing the battery, use care not to touch any of the circuitry. Static from your body transferred to these surfaces may damagethe t

2-12ResynchronizationResynchronization may be necessary due to the securitymethod used by this system. The transmitter does notsend the same signal tw

viiHow to Use this ManualMany people read their owner’s manual from beginningto end when they first receive their new vehicle. If youdo this, it will

2-13To close the sliding side door from outside, use theoutside door handle to slide the door toward the front ofthe vehicle.When the door slides clos

2-14To close the sliding door from inside, grasp the insidehandle and slide the door toward the front of the vehicleto a closed position.Make sure the

2-15To open the front portion of a 60/40 door from theinside, pull the handle towards you and push open the door.To open the rear portion of a 60/40 d

2-16Rear DoorsCAUTION:It can be dangerous to drive with the rear door(s)or rear swing-out windows open because carbonmonoxide (CO) gas can come into y

2-17To open the driver’s side rear door, pull the latch releaseat the inside edge of the door.Both rear doors can be opened past 90 degrees byopening

2-18Parking at NightPark in a lighted spot, close all windows and lock yourvehicle. Remember to keep your valuables out of sight.Put them in a storage

2-19New Vehicle “Break-In”NOTICE:Your vehicle doesn’t need an elaborate“break-in.” But it will perform better in the longrun if you follow these guide

2-20LOCK (B): This position locks your ignition, steeringwheel and transmission. It’s a theft-deterrent feature.You will only be able to remove your k

2-21Starting Your 8.1L V8 Engine1. With your foot off the accelerator pedal, turn theignition key to START. When the engine starts, letgo of the key.

2-22Starting Your 4.3L V6, 5.0L V8 or 5.7L V8 Engine1. With your foot off the accelerator pedal, turn yourignition key to START. When the engine start