Chevrolet Tavera Spezifikationen

Part No. : 28283507Revision No. 04Revision Date01/2014/1,000BS4 (Neo3)General Motors India Pvt. Ltd.All information, illustrations and specifications

42. After starting the engine, let it run for about 1 to 2 minutes with idle speed (avoid acceleration or driving off the vehicle).3. Avoid engine r

948. When descending a slope, shift to a lower gear to gain retardation effect of the engine.9. Repeated use of the foot brake on a long downgrade wil

9510. When driving across a shallow river or patch of water, extreme care must be exercised or water may enter the air duct causing serious engine dam

9612.The brakes are provided with wear indicator device which produces a metallic frictional sound (squeal) while driving when the brake pad

972. After accelerating, shift to a higher gear and engage the clutch smoothly.3. After shifting to top or overdrive, maintain your speed constant as

984. Always drive with the coolant temperature within the normalrange.5. Under-inflated tires cause deterioration in fuel economy.

99IN CASE OF EMERGENCYEmergency stop1. If you must stop your vehicle on the road for some reason, pull your vehicle over to the left side of the road

100Emergency startingWARNINGNever tow the vehicle to start the engine because when the engine starts it could cause a collision with the towing vehicl

1014. Increase the idling speed of the engine on the other vehicle a little and start the engine on the damaged vehicle.5. If the engine starts, disco

102WARNINGDo not pump the brakes when the power assist has been lost, except when necessary to maintain steering control on slippery surf

Front wheels off the ground1. Transmission in Neutral.2. Maximum speed: 60km/h.3. Maximum distance: 80km.For distances over 80km disconnect the rear p

5OPERATION AND CARE OF VEHICLEEvery component and system of your vehicle should be checked according to “CONTROLS AND INSTRUMENTS”, “BEFORE DRIVIN

104Bleeding of fuel system If the fuel tank is emptied, air might be allowed to go into the fuel system. With air in the fuel system, smooth flow of f

Vehicle front side12Velcro pocketJack BarJack Bar storage ( Insert the Jack Bar in velcro pocket given on left side of cushion of 3rd row front facin

106Preparation1. Park on a level surface and set the parking brake firmly.2. Set the transmission to “REVERSE”.3.4. Turn off the ignition.5. Block the

1077. Place the jack at correct jacking point.Front : Concave position on bottom surface of attachment bracket under the side frame.Rear: Under the R

108WARNINGDo not jack up the vehicle on a slope or a soft ground. It is very dangerous. Do not jack up on any points other than specified jack points.

1092. Install and semi-tighten the wheel nuts and lower the wheel to the ground.3. With the wheel wrench, tighten the wheel nuts in sequence as shown

110SERVICE AND MAINTENANCEIn order to maintain safety and economical operation, it is suggested that periodic inspection and maintenance be performed

111Maintenance schedule I: Inspect and correct or replace as necessary A: AdjustR: Replace or change

112Maintenance schedule I: Inspect and correct or replace as necessary A: AdjustR: Replace or change

113102 108 114 120

61 Side Vent2 Center Vent3 Wiper & Washer Control Lever4 Exterior Lights Control Lever5 Instrument panel6 Glove Box7 Heating and Air Conditioni

114Maintenance schedule I: Inspect and correct or replace as necessary A: AdjustR: Replace or change

115Maintenance schedule I: Inspect and correct or replace as necessary A: AdjustR: Replace or change

Maintenance schedule under severe driving conditions Severe driving conditions116Repeated short tripsDriving on rough roadsDriving on dusty roadsDrivi

MAINTENANCE GUIDEREGULAR INSPECTIONEngine oil levelPull out the level gauge rod ( oil dipstick).Wipe clean it and reinsert.Again pull it out and check

To protect against CO entering the vehicle, inspect the exhaust system and body according to the following recommendations :Ÿ At each oil change.Ÿ Whe

119Catalytic ConverterThe catalytic converter reduces the amount of harmful substances in the exhaust gas.The catalytic converter requires the use of

120Power steering / Fan drive beltCheck that the tension of Power steering / Fan drive belt is in the below specified range when measured at the midd

121! Water draining from the air conditioning is normal when it is in use.NOTECAUTIONCoolant levelWARNINGWhen the coolant is heated to a high temperat

Parking brake lever travelDash panel parking brake lever travel must be 8 to 12 notches (When pulled with a force of 30 kg.)For floor mounted parking

123WARNINGIf the brake indicator light comes on while driving, the fluid reservoir should be filled to the level mark with the recommended hydraulic b

7STEERING COLUMN CONTROLSSteering wheel and horn buttonThe horn button on the steering wheel operates the horn.Avoid turning the steering wheel while

Windshield washer solution levelCheck that the washer tank is filled sufficiently with solution. Also check the operating condition of the

125Vehicle Storage Storage for a long period of time. If the vehicle is to be stored for several months:Ÿ Wash and wax the vehicle.Ÿ Have the wax in t

126Clutch pedal free play and height Standard value : mm(1) Free play : 5-15(2) Height : 168-178(3) Clutch diameter : D260Brake pedal free play, heigh

127PERIODIC MAINTENANCEAir cleanerUse of fouled air cleaner element not only cause a deterioration in the engine output but also give a raise in fuel

128Engine Oil FilterLoosen the oil filter by tuning it counterclockwise with a filter wrench.With a rag, wipe the fitting face of the oil pump clean s

129Parking and service brake All brakes are self-adjusting.Brakes are adjusted by repeated stepping on the brake pedal.The dash panel parking brake ad

130Tire rotationWhen the front and rear tires are the same size, rotate the wheels as shown in the figure.After rotation, adjust the front and rear ti

Tire inflation pressureStandard inflation pressure for tires are listed below.Check tire pressure when the tires are cold (after the vehicle

Tire pressure labelThe tire pressure label is located on the frame of driver's side.Specific gravity of battery electrolyteIf your new vehicle ha

Cleaning of batteryIf the external part of the battery is fouled, clean with tepid water. Apply a thin coat of vaseline or grease onto the battery ter

8“START” : Turning the key to this position will start the engine. The key returns to the “ON” position when released.WARNINGNEVER attempt to turn the

134HeadlightsProper aiming of the headlights is most important in ensuring sufficient illumination on the highway without blinding other mot

Rear combination lightUnscrew each of the two screws securing the lens135License plate lightUnscrew the two screws securing the lens.

Dome lightThe lens can be removed easily by hand then remove the bulb from the socket by pulling it.Replacing light bulbsWhen replacing a bulb, make s

137BulbWattage x QuantityRemarkBULB SPECIFICATION1 Headlamp (High/Low) 60/55W x 2 Halogen2 Parking Lamp 5W x 23 Turn Signal Lamp 21W x 24 Turn Signal

Normal Burned outFuse junction blockThe fuse junction blocks are installed under the instrument panel on the drivers side and in the engine compartmen

139Fuse Box: Engine Room D30 ACONDFAN(30 A(P / W)20ALAMPLAMPLAMP8511315RR DEFLAMP118HORNCOND4LAMP3710LAMP962DIMMER8USE SPECIFIED FUSES ONLY.UNSPEC

140Fuse No.C-2C-3C-4C-5C-6Capacity15A20A10A15A15AFunctionRR. Defog, I/P Cluster,FT. Wiper WasherFT. WIPERRR. WIPERTURN, BACKAUDIO (ACC), CIGARFuse Box

In order to obtain maximum performance and longest service life from your CHEVROLET vehicle, it is very important to use lubricants and diesel fuel

142Diesel engine must be operated only on commercially available diesel fuel meeting specifications of Cetane no. 48 & above. Only use diesel fue

LUBRICATIONLubricants should be carefully selected according to the lubrication chart. It is also important to select viscosity of l

9Light switchTo turn on the clearance lights, tail lights, license plate lights, instrument panel lights, turn the switch knob clockwise. To turn on t

OIL VISCOSITY CHART FOR REAR AXLE144

OIL VISCOSITY CHART FOR TRANSMISSION CASE145

LUBRICATION GUIDEChanging engine oilDrain the engine crankcase completely by removing the drain plug on the lower part of the oil pan while the engine

(D)(L)Changing transmission oilDrain the transmission case by removing the drain plug (D) on the lower face of the transmission case. Fill the transmi

Changing power steering fluid PSDraining1. Jack up the front wheels until they are clear of the ground.2. Remove the fluid hose between the steering

2. With the engine stationary, turn the steering wheel fully in both directions several times.While bleeding check the fluid level and replenish if ne

5. Bring the steering wheel to the straight-ahead position, stop the engine, and check that the level of fluid in the fluid reservoir does not rise. I

151G2 & 4 Stroke/DI/TCIC/CRDFi four cylinder water cooled inline cylinder engine with piezo technology fuel injectionMAIN DATA AND SPECIFICATIONSD

152Service change engine oil capacity(with filter changes) liters(without filter changes) litersCoolant capacity litersFuel tank capacity litersOil pa

153MAIN DATA AND SPECIFICATIONSSpiral bevel & hypoid gear, semi-floating Gear ratio 4.11.8L2.75 - 4.18Recirculating ball10-302 ± 20 030' ± 60

CAUTION10Dimmer switchThe headlight beam is alternately switched from high to low or from low to high each time the lever is raised. The headlight hig

154Mechanical internal-expanding, action on rear wheels.IP mounted 8-12 (when pulled with force of 30kg)Floor mounted 7-10 (when pulled wit

155Service and Warranty

156

157Service Certificate1st Owner Customer nameRegistration no.2nd Owner Customer nameRegistration no.3rd Owner Customer nameRegistration no.

158Predelivery Inspection andVehicle Delivery CHEVROLET R ’s / ASO’s Stamp and SignatureetailerCity, dateBefore delivering the vehicle we carried

Owner’sStatement of Acceptance I hereby certify that the vehicle has been delivered in an orderly and proper operating condition, includin

160

1611000Km/30 days Reassurance check-upVIN no. :PDI no. :Date of serviceDate of deliveryRetailer codeCustomer's nameCustomer's tel no. :I con

162General Status reviewCheck closing efforts of doors, key less entry system, sunroof & other functionsUnder hoodVisually check routing, leaks &a

163CHEVROLET 1st Service Check Six months /5000 kms whichever occurs earlierInspection (Retain with Job card)Customer's SignatureLabour is free &

11Windshield WipersTo operate the windshield wiper, turn the ignition ON and move the windshield wiper / washer lever downward. The windshield wipers

164Delivering retailer's stamp & dateI hereby certify that the work has been carried out as per theschedule.Servicing / ASO stamp & dat

165CHEVROLET 3rd Service Check Eighteen months/15000 kms whichever occurs earlierInspection (Retain with Job card)Customer's SignatureLabour &

166Delivering retailer's stamp & dateI hereby certify that the work has been carried out as per theschedule.Servicing / ASO stamp & dat

167MAINTENANCE RECORD SHEET(Repair category - Free Service/Paid Service/Running Repair/Acc. Repair)R.O. No.RepairCategoryDetails of Repair DoneNa

168MAINTENANCE RECORD SHEET(Repair category - Free Service/Paid Service/Running Repair/Acc. Repair)R.O. No.RepairCategoryDetails of Repair DoneNa

BatteryBattery type :Battery make :Battery number :Important InstructionsnThe battery must be fitted firmly in the cradle.nConnecting cables and conne

Battery Service RecordDateSpecific GravityVoltageRemarksRetailer stamp &signature170

1711. SCOPEGeneral Motors India Private Limited, a private limited company incorporated in India under the Companies Act 1956 and h

172lThe obligation under this New Vehicle Warranty is limited to the repair of the new motor vehicle at no charge by the CHEVROLET authorized retailer

1733. WHAT IS NOT COVEREDPlease read the followings carefully; a. Failure to have the required periodic inspection and required service perf

12Windshield Washer To spray the washer fluid on the windshield.Ÿ Turn the Ign. switch ON.Ÿ Pull the windshield wiper / washer lever towards you.The l

174so forth; compensation for inconvenience or commercial losses; all other consequential costs relating to the owner being unable to use the ve

1757. REQUIREMENTS FOR WARRANTY WORKTo have warranty work carried out, present the warranty & service booklet to the authorized Chevr

176Subject to other terms of the warranty policy and the conditions and obligations laid down hereunder, General Motors India Pvt. Ltd., hereaf

177In-use emission standards on the vehicle not meeting any such given legal/ regulatory requirement, during inspection by such authorities.11

1781. Vehicle : The Motor Vehicle approved for sale within India under the provisions of Central Motor Vehicle Rules, 1989 or any subsequent amend

179Annexure - II1 Catalytic Converter***2 Exhaust manifold gasket3 Electronic Control Module 4. Manifold Absolute Pressure Sensor5. Mass Air Flow Sens

180CHEVROLET SALES INDIA SALES AND SERVICE NETWORKLm Indicates Chevrolet Authorized Service Center (ASC) are authorized to carry out Periodic Maintena

181Workshop :Barwala, Naraingarh Road, Ambala City - 134 003Tel.: 0171 - 2678013BHIWANIL Shailesh AutomobilesShowroom & Workshop :Rohtak Road, Bhi

KANGRAL Himachal Autowheels Pvt. Ltd. (Platinum Chevrolet)Showroom & Workshop :N.H 20 Kachhiary, Kangra - 176001Tel. : 01892 - 260600/260601MAN

NAWASHAHARL Aakriti WorldShowroom & Workshop : Chandigarh Road, Nawashahar, Punjab - 144 514Tel. : 01823 - 285656Telefax : 01823 - 285858PATIALA L

13Windshield washer tankThe tank should be filled only with plain water, GMI genuine washer solution or equivalent.In cold weather, do not fill the wi

Workshop 1 :G-109A, Sitapura Industrial Area, Jaipur - 302 004Tel. : 0141 - 5122333, 5113636, 5143737, 5122797, 5122798, 5143636, 4

MIRZAPURL Saraswati IndustriesShowroom & Workshop :Pili Kothi, Station Road, Mirzapur - 231001Tel. : 05442 - 223923NOIDAL Shiva MotorsShowroom :G-

HALDWANIL Analysis MotorsShowroom :Rampur Road, Near Sushila Tewari Hospital, Haldwani - 263139, Distt. NainitalTel.: 9258071041,9258071009Workshop :7

VASCO-DA-GAMAL Subrai Motors Pvt. Ltd.Showroom & Workshop :F L Gomes Road, Vasco-Da-Gama, Goa - 403 802Tel. : 0832 - 2517421 / 22Fax : 0832 - 2513

SURATL Empire Cars Pvt. Ltd.Showroom & Workshop :Plot No. 3, Near Rangoli Hotel, Rundh, Dumas Road, Surat - 395007Tel. : 0261 - 6713300 / 33L Mona

BARAMATIL Mota Automotive Pvt. Ltd.Showroom & Workshop :41 / 1 / B / 17, Nira Road, Kasba, Tehsil - Baramati, Dist - Pune - 413102Tel. : 02112 - 2

NANDEDL Bafna AutomotivesShowroom & Workshop :Gut No. 235, Pimpalgaon (Mahadeo), Nanded – Akola Road, Nanded - 431 607Tel. : 02462 - 274069 / 6520

Workshop :Pioneer Estate Corporation, 133-134, Pokhran Road No.2, Opp. Oswal Park, Thane (West) - 400601Tel. : 022 - 66040000Fax : 022 - 66040102L Ang

SOUTH ZONESTATE - ANDAMAN & NICOBARPORTBLAIRL Group EngineersShowroom :Prem Nagar Junction, (SY No 1394/1), Haddo Post Port Blair - 744102Tel. : 0

Workshop :Plot No. 95 & 96, Wood Complex, Near Ayyappa Temple, Nellore - 524004Tel. : 9247000022RAJAHMUNDRYL Orange Auto Pvt. Ltd.Showroom & W

 !"#

140 6FLDR SECURITYTE/LOGSCAN/AS2Push tooperateHazard warning flasher switchWhen the switch button is pushed in, all signal lights flash regardless of

BELLARYL Bellad Enterprises Pvt. Ltd.Showroom & Workshop :Near Bellary Rolling Mills, Anantpur Road, Bellary - 583 101Tel. : 08392 - 261234 / 5Fax

KOLLAML Deedi MotorsShowroom :Post Office Junction, Pallimukku, Kollam - 691 010Tel. : 0474 - 3257777 / 2725959Fax : 0474 - 2725900Workshop :Cantonmen

Showroom & Workshop 2 :No. 8-NP, Developed Plot, Guindy Industrial Estate, Ekkattuthangal, Near Kasi Theatre, Chennai - 600097Tel. : 044 - 2345894

VELLOREL Sayar CarsShowroom & Workshop :S.F. No. 3004, New By Pass Road, Near Collectorate, Vellore - 632004Tel.: 0416 - 2222017197

EAST ZONESTATE - ARUNACHHAL PRADESHSILCHARL Smart Motors Pvt. Ltd.Showroom & Workshop : NH-54, Ramnagar, Silchar - 788 008Tel. : 03842 - 268701, 9

JAMSHEDPURL Narbheram Motors Pvt. Ltd.Showroom & Workshop :M-4, Phase-VI, Adityapur Industrial Area, P.O. Gamaria, Jamshedpur - 832 108Tel. : 0657

IMPHALL Rajpri Enterprise Showroom & Workshop : Chigmeirong Mamang Leikai,Imphal East, Imphal - 795 001Tel. : 0385 - 2421183DIMAPUR L Urban Statio

INTERNATIONALSRI LANKAL Mag City Motor Company Pvt. Ltd.Showroom & Workshop :No. 320A, Darley Road,Colombo - 10, Sri LankaTel. : 0094777410407BHUT

202

150 Head lamp leveling deviceAdjust the headlight beam level with the following switch positions according to the number of passengers and load condit

 !"""

0 169 seaterSpecificationSeating PositionSr. No.1. One person in the driver seat 02. The driver, plus one passenger in the front seat farthest from th

METERS AND INDICATOR LIGHTS1 Temperature gauge2 Turn signal indicator lights3 Odometer4 Speedometer5 Fuel gauge6 Trip counter7 Reset knob178 Engine ta

18SpeedometerThe speedometer indicates the vehicle speed in kilometers per hour (km/h).OdometerThe odometer registers the accumulated distance in kilo

19Trip counter and reset knobA reset knob for the trip counter is located on the lower section of the meter. To reset the trip counter, push the knob

20Fuel gaugeThe fuel gauge indicates the level of fuel within the fuel tank when the starter switch is “ON”.The letters “F” and “E” represent “Full” a

21Turn signal indicator lightsWhen the turn signal switch or hazard warning flasher switch is turned on, the turn signal indicator light flashes to in

NOTE22Water separator indicator light DThe water separator indicator light illuminates when the water level in the fuel filter exceeds a certain le

Oil pressure indicator lightThe oil pressure indicator light comes on when the starter switch is “ON”. The lamp should go out after engine starts.If t

Dear Customer,Welcome to the Chevrolet family. We wish to thank you for choosing Chevrolet Tavera.It is our constant endeavor to provide you with prod

Brake system indicator lightThe brake system indicator light comes on when the parking brake lever is pulled with the starter switch “ON”, or the brak

25Malfunction indicator lamp (MIL)The MIL illuminates briefly as you turn the ignition ON, before you start the engine. This means that

26Engine coolant temperature warning lampThis lamp i engine coolant gets overheated. If you have been operating your vehicle under normal driving cond

27Glow plug indicator lampThe glow plug indicator illuminates if there is a temperature and ambient pressure conditions demand when the ignition is sw

28Floor mounted parking brake VThe parking brake acts on the rear wheels. The parking brake lever is located between the front seats. To set the par

29After using the ash tray, push it back in completely. If not, the flame of the cigarette may cause other cigarette butts to burn, res

30FLOOR CONTROLSTransmission gearshift lever MTThe transmission gearshift lever controls fully-synchronized transmission. The gearshift pattern is sh

31Brake pedalAvoid stopping hard by operating the foot brake pedal in a smooth manner. When descending a slope, it is always advisable to use the foot

32Clutch pedal MTThe clutch pedal should be fully depressed when disengaging. Not doing so, may result in grating of the gears.Do not allow your fo

33Center ventsTwo center vents are provided on the instrument panel.The knobs at the center part of the grille controls direction of air flow vertical

V or * : The asterisk and V in this manual, signify an item of equipment that is not included on all vehicles. Such items include engine

34OFF ON : The light stays off regardless of the door position.: The light will turn on and stay on regardless of the door position.Dome light VFro

35Assist grip with coat hook VEach assist grip is attached to the roof above the side window of assist seat and rear seat. The grip above the Rear R

36HEATER-DEFROSTER AND AIR CONDITIONING V1 Air distribution mode knob2 Fan control knob 3 Temperature control knob4 Air conditioning (AC) switch5 Air

37Air dThe knob regulates air flow from the heater, defroster and air conditioning or ventilating outlets.1. FACE OUTLET ( Air to your face)2. BI-LEVE

38BI-levelAir is discharged from the upper air outlets and the floor air outlets.Foot outletAir is delivered from the foot outlet.

39Foot outlet and defrosterAir is delivered from the foot outlet with a small amount from the defroster outlets and the side window defroster outlets.

40To defog glass:• Set air distribution mode knob to DEFROST. If set to FOOT/DEFROST, air will be sent to feet simultaneously with defogging. (Since a

41Temperature control knob VThe temperature control knob controls the temperature of the air that comes through the air vents. Turn the knob

42Fan control knob VYou may control the rate of airflow coming from the system by turning the fan speed control knob. Turn the knob clockwise

43Air conditioning (AC) switch VPush this switch to operate the air conditioning system. The light-emitting diode in this switch lights up as the sy

Starting engine ...85Before driving off ...

44NOTEWHEN REMOVING FROST AND FOG FROM THE FRONT AND SIDE GLASSESTurn the Air distribution mode knob to the " DEFROSTING" position.

45Rear cooler control lever VBy sliding this lever, cool air is delivered from the cooler outlets, when the AC & Blower switch is in ON position.

46Sun VisorsYour vehicle is equipped with sun visors to protect the driver and passenger* from glare.You can swing the sun visors up and down, and to

47Power window VWindows on either side of the vehicle can be opened or closed with the switch at the driver’s side. The windows operate only whe

48• To assure the safety of children and others, make sure that all passengers have their hands, etc. inside the vehicle before opening and

49Glove compartmentThe glove compartment is located on the passenger's side end of the instrument panel.To lock : Insert the key and turn it cloc

50Spare wheel hangerThe spare wheel is secured to the rear part of the chassis frame by chain. To lower the spare wheel, open the back door and take o

51Rear side1 Turn signal lights2 Back up lights3 Tail and stop lights4 ReflectorExternal lightsFront side1 Headlights and clearance lights2 Front turn

52Tilt Quarter Window V1. Pull the handle inward to unlock the window.2. Push the handle outwards to open the window.3. To hold the window in the ope

53Engine hood release leverTo raise the engine hood, unlock the hood lock by pulling the release lever under the instrument panel on the driver's

54OpenNOTEFuel tank filler capThe vehicle is equipped with a fuel door release mechanism.Pull up on fuel filler door release lever located on the floo

55KeyTwo keys are provided with your new CHEVROLET. The key number is stamped on the key number plate. Record the key number and keep it in a safe pla

56UnlockLockInside door handle/Door lock (inside)The door can be opened by pulling the inside door lock lever.The door can be locked by pushing in the

57UnlockLockLocking and unlocking the power lock doors from the insidePush the driver's side door lock to lock all the vehicle doors and pull to

58Back door inner handle VThe back door can be opened by pulling the back door inner handle.Unlock Lock Back door lock (Inside) The back door can b

59LOCKChild-proof door locksRear doors can be locked by closing the door with the child-proof lever pushed towards arrow. Rear doors can not be

60Captain seat's with arm rest - Front and second row seat's onlySeat slide adjustmentTo move the seat forward or backward :1. Pull up and

61Seat backFront seat back inclination angle can be adjusted by raising the adjust lever on door side of seat.WARNING•To reduce the risk of injury and

62Head restraint VHeight adjustmentThe head restraints are adjusted for height. You need both hands to adjust the restraint. Press the release button

63Folding type second seat VFolding the second seatThe second seat can be folded forward to provide additional luggage space.Pull any of the lever upw

1The following information is important for the proper care and economical operation of your CHEVROLET vehicle and should be thoroughly understood bef

64Folding type second seat VUnfolding the second seat1. Lift the entire seat. Some variants require pulling of lever as illustrated.2. Raise the seat

65Folding the jump seat1. Tilt seat cushion (1) upward.2. Tilt seat trigger (2) downward.3. Secure the seat lock strap (3) to the seat back mounted ho

66Folding type third seat Folding the third seatVThe third seat can be folded forward to provide additional luggage space.1. Press the head rest s

674. Pull the seat latch lever towards your side to detach the seat latch.5. Lift the entire seat with rod and push the seat assembly forward.Do n

686. Attach the band (with hook) provided below the third seat to clasp on to the head rest of the second seat back.Removing the third seat V To re

69200 mmFolding type third seat V Unfolding the third seat1. Remove the clasping band from the headrest rod of the second seat back.2. Lower the th

70Front seat and rear seat lap/shoulder beltsThe front seat is equipped with a 3-point seat belt which features one buckle for the lap and shoulder be

71(Continued)Position the lap portion of the belt across the lap by the hips as low as possible. Then adjust to a snug fit by holding the shoulder por

72(Continued)The shoulder portion of the front seat belt has an “Emergency locking retractor” which is designed to lock during a sudden stop or impact

Seat belt inspection and care• Periodically inspect belts, buckles, latch plates, retractors, and anchors for damage that could lessen the ef

Engine number D The engine number is stamped / punched on the right side of the cylinder block adjacent to oil filter.OVERLOADINGOverloading not onl

Inside rearview mirror: day and night VTo adjust, move the mirror right or left and up or down.Switch the mirror to the night operation position to

DRIVER'S CHECK LIST(REGULAR INSPECTION)The following checks should be performed to maintain safe and dependable vehicle operation. If an

762. Check wheel nuts for looseness. Wheel nut torque: 118N·m3. Check chassis springs for damage.

774. Check operation of lights.5. Check level of electrolyte in each cell of the battery.Not required in vehicles fitted with maintenance free batter

78Check the setting angle of the rearview mirrors.7.UnlockLockCheck operation of the door locking mechanism.8.

799. Check clutch pedal free play, height and function.Within engine compartment1. Check engine oil level.

80Check that the level of the power steering fluid is within “MAX” and “MIN” level. PS2.Check the tension of the power steering / fan drive belt.3.

WINDOW WASHER Back door side 814.Check that the level of the windshield washer solution in reservoir tank is within “MAX” and “MIN” level.

5. Check that the level of the engine coolant in reservoir tank is within “MAX” and “MIN” level.WARNINGCoolant level check or replenishment should be

83After starting engine1. With the engine running, check that oil pressure indicator light, generator indicator light, water separator indicator light

3OPERATION OF NEW VEHICLEThe subsequent performance and the life of your vehicle are directly influenced by the care and treatment that your vehicle r

843. Check for abnormal engine noise and color of exhaust gases.

85DRIVINGProper care and operation will not only extend the life of your vehicle but also improve oil and fuel economyPREPARATION FOR STARTING ENGINE1

2. Crank up the engine by turning the starter switch key fully clockwise. Release the key as soon as the engine starts. The key will return automatic

87LockBEFORE DRIVING OFF1. Lock the doors.2. Adjust the seat position.

883. Adjust the inside and outside mirrors.4. Fasten the seat belt.

89STOPPING ENGINETurn the starter switch to the “ACC” or “OFF” position.PARKINGWhen leaving your vehicle unattended:l Set the parking brake.l When pa

90WARNINGDo not park your vehicle over combustible materials, such as dry grass or leaves.They could touch the hot exhaust system and ignite.Do not le

912. If abnormal noise or smell becomes noticeable while driving, stop the engine and check to locate the cause of trouble.3. If the indicator lights

924. Avoid needless hard acceleration and hard stops.5. Do not drive with your foot resting on the clutch pedal as it produces a partly disengaged con

936. Allow the vehicle to stop completely before shifting to reverse or to first gear after reversing.When starting the vehicle from rest, it is alway