Chevrolet 2002 Express Van Bedienungshandbuch

1-3Power Seat (Option)If your vehicle has a power seat on the driver’s orpassenger’s side, you can adjust it with these controlslocated at the front c

2-29Move the lever up as far as it will go.3. Move the ignition key to LOCK.4. Remove the key and take it with you. If you canleave your vehicle with

2-30Torque LockIf you are parking on a hill and you don’t shift yourtransmission into PARK (P) properly, the weight of thevehicle may put too much for

2-31Parking Over Things That BurnCAUTION:Things that can burn could touch hot exhaustparts under your vehicle and ignite. Don’t parkover papers, leave

2-32Engine ExhaustCAUTION:Engine exhaust can kill. It contains the gascarbon monoxide (CO), which you can’t see orsmell. It can cause unconsciousness

2-33CAUTION:It can be dangerous to get out of your vehicle ifthe shift lever is not fully in PARK (P) with theparking brake firmly set. Your vehicle c

2-34Tilt Wheel (Option)A tilt steering wheel allows you to adjust the steeringwheel before you drive. You can also raise it to thehighest level to giv

2-35Turn and Lane Change SignalsThe turn signal has two upward (for right) and twodownward (for left) positions. These positions allow youto signal a

2-36Windshield WipersYou control the windshield wipers by turning the bandwith the wiper symbol on it. (Off): Turn the band to this symbol to turn off

2-37Cruise Control (Option)+ : Resume/Accelerate | : On : Set:OffWith cruise control, you can maintain a speed of about25 mph (40 km/h) or more wi

2-38Setting Cruise ControlCAUTION:If you leave your cruise control switch on whenyou’re not using cruise, you might hit a buttonand go into cruise whe

1-4But don’t have a seatback reclined if your vehicle is moving.CAUTION:Sitting in a reclined position when your vehicle isin motion can be dangerous.

2-39Resuming a Set SpeedSuppose you set your cruise control at a desired speedand then you apply the brake. This, of course, shuts offthe cruise contr

2-40Reducing Speed While Using Cruise ControlPress in the button at the end of the lever until youreach the lower speed you want, then release it.To s

2-41Exterior LampsThe exterior lamp control is located on the driver’s sideof the instrument panel.The exterior lamp control has three positions:OFF:

2-42Headlamps On ReminderA tone will sound when your headlamps are turned onand your ignition is in OFF, LOCK or ACCESSORY. If you need to use your he

2-43Center High-Mounted StoplampYour vehicle’s center high-mounted stoplamp is locatedabove the rear doors at the center of the vehicle.If items are l

2-44Dome LampsThe dome lamps will come on when you open a door.You can also turn the dome lamps on by moving theinstrument panel brightness thumbwheel

2-45Reading Lamps (Option)If your vehicle has reading lamps, press the button nextto the lamp to turn the lamp on or off.MirrorsInside Day/Night Rearv

2-46Power Remote Control Mirrors (Option)If you have power mirrors, they can be adjusted frominside the vehicle.Select the mirror you want to move by

2-47Convex Outside MirrorYour passenger’s side mirror may be convex. A convexmirror’s surface is curved so you can see more from thedriver’s seat.CAUT

2-481. To adjust the mirrorswhen towing a trailer,turn the mirror bypushing the mirror head toward the front of the vehicle.2. Turn the mirror head so

1-5Rear SeatsGetting Into the Rear SeatsTo make it easier for passengers to get into the rearseats, use the fastener spot on the headliner and safetyb

2-49Storage CompartmentsYour front storage compartment is at the center of theinstrument panel extension, by the floor. To open thecompartment, press

2-50NOTICE:Holding a cigarette lighter in with your handwhile it is heating can make it overload,damaging the lighter and the heating element.Just pus

2-51Accessory Power OutletYou can plug accessory electrical equipment into anaccessory power outlet. Just pull on the outlet cover to remove it and fo

2-52The Instrument Panel - Your Information SystemThe main components of your instrument panel are the following:A. Lamp ControlB. Air VentsC. Instrum

2-53Instrument Panel ClusterUnited States version shown, Canada similarYour instrument panel cluster is designed to let you know at a glance how your

2-54SpeedometerYour speedometer lets you see your speed in both miles per hour (mph) and kilometers per hour (km/h).Your odometer shows how far your v

2-55Trip OdometerThe trip odometer cantell you how far yourvehicle has beendriven since you lastset the trip odometer to zero.To reset the trip odomet

2-56When one of the warning lights comes on and stays onwhen you are driving, or when one of the gages showsthere may be a problem, check the section

2-57If the air bag readiness light stays on after you start thevehicle or comes on when you are driving, your air bagsystem may not work properly. Hav

2-58VoltmeterWhen your engine is notrunning, but the ignition ison (in the RUN position),this gage shows yourbattery’s state of charge in DC volts.Whe

1-62. Locate the blue or yellow handle on the inboard sideof the seat. If the vehicle has floor mats, the pins willbe located under a flap that has be

2-59Brake System Warning LightWhen the ignition is on, the brake system warning lightwill come on when you set your parking brake. The lightwill stay

2-60Anti-Lock Brake System Warning LightWith the anti-lock brakesystem, this light will come on when you startyour engine and may stayon for several s

2-61Malfunction Indicator Lamp (ServiceEngine Soon Light in the United States or Check Engine Light in Canada) (4.3L, 5.0L & 5.7L Engines and 8.1L

2-62NOTICE:Modifications made to the engine, transmission,exhaust, intake or fuel system of your vehicle orthe replacement of the original tires with

2-63If the Light Is FlashingThe following may prevent more serious damage toyour vehicle:Reducing vehicle speed.Avoiding hard accelerations.Avoiding s

2-64Have you recently changed brands of fuel?If so, be sure to fuel your vehicle with quality fuel. See “Fuel” in the Index. Poor fuel quality will ca

2-65Malfunction Indicator Lamp (ServiceEngine Soon Light) (Check Engine Light)(8.1L Gasoline Engine -- Except California)United States CanadaIf this l

2-66Oil Pressure GageThe oil pressure gage showsthe engine oil pressure inpsi (pounds per square inch)when the engine is running. Canadian vehicles in

2-67Security LightThis light will come onbriefly when you turn theignition key to START.The light will stay on until the engine starts. If the lightfl

2-68Fuel GageUnited States CanadaThe fuel gage, when the ignition is on, tells you abouthow much fuel you have left in your tank.The gage will first i

1-75. Stow the locking pin on the rear of the seat base in the hole that is provided.6. Repeat this procedure for the pin on the other seat base.7. Pu

3-3-1Section 3 Comfort Controls and Audio SystemsIn this section, you’ll find out how to operate the comfort control and audio systems offered with yo

3-2Comfort ControlsThis section tells you how to make your air system workfor you.With these systems, you can control the heating, coolingand ventilat

3-3Mode KnobThe right knob changes the airflow setting.(Vent): This setting directs air through theinstrument panel vents.(Bi-Level): This setting div

3-4Fan KnobThe knob on the left side of the control panel regulatesthe fan speed. The knob has four speed positions. Toincrease airflow, turn the knob

3-5Rear Heater (Without Air Conditioning) (If Equipped)If you have a rear heater (without rear air conditioning),the thumbwheel for this feature is lo

3-6For warmer air, turn the knob toward the red area, andfor cooler air, turn the knob toward the blue area.To regulate the location of the airflow, a

3-7Air ConditioningBefore using your vehicle’s air conditioning, open thewindows to clear the vehicle of hot air. This reduces thetime it takes for yo

3-8Rear Window Defogger (If Equipped)If you see lines running across the rear windows, yourvehicle has a rear window defogger. The lines warm the glas

3-9Ventilation SystemFor mild outside temperatures when little heating or coolingis needed, use vent to direct outside air through your vehicle.Air wi

3-10Ventilation TipsKeep the hood and front air inlet free of ice, snow, orany other obstruction (such as leaves). The heaterand defroster will work f

1-8For the remaining rear seats, stow the safety beltlatch plate on the clip at the window trim.Replacing the Rear SeatsCAUTION:A seat that isn’t lock

3-11Setting the Clock for Systems with RadioData SystemYour radio may have a button marked with an H or HR to represent hours and an M or MIN to repre

3-12Finding a StationAM FM: Press this button to switch between AM, FM1and FM2. The display shows your selection.TUNE: Turn this knob to tune in radio

3-13To adjust the treble, Press and release AUDIO until TREappears on the display. Then press and hold the up arrowto increase treble. T and a positiv

3-14To adjust balance or fade to the middle position, selectBAL or FAD. Then press and hold AUDIO for morethan two seconds until you hear a beep. L an

3-15Finding a StationAM FM: Press this button to switch between AM, FM1and FM2. The display shows your selection.TUNE: Turn this knob to choose radio

3-16To adjust the treble, press and release AUDIO until TREappears on the display. Then press and hold the up arrowto increase treble. T and a positiv

3-17To adjust balance or fade to the middle position, selectBAL or FAD. Then press and hold AUDIO for morethan two seconds until you hear a beep. L an

3-181 PREV (Previous): Press this pushbutton to go to theprevious selection on the tape if the selection has beenplaying for less than 3 seconds. If t

3-196 RPT (Repeat): Press this pushbutton once to hear aselection over again. RPT will appear on the display.The current selection will continue to re

3-20AM-FM Stereo with Compact Disc Player(If Equipped)Playing the RadioPWR (Power): Press this knob to turn the system onand off.VOL (Volume): Turn th

1-91. Position the seat into the open slots in both rails.Push the seat forward in the rail, hooking both seatbases onto the pins inside of the rails.

3-21Setting Preset StationsThe six numbered pushbuttons let you return to your favorite stations. You can set up to 18 stations(six AM, six FM1 and si

3-22Adjusting the Speakers (Balance/Fade)AUDIO: To adjust the balance between the right andleft speakers, press and release AUDIO until BALappears on

3-231 PREV (Previous): Press this pushbutton to go to theprevious track if the current selection has been playingfor less than eight seconds. If this

3-24Compact Disc MessagesIf the disc comes out, it could be for one of thefollowing reasons:If you’re driving on a very rough road. When theroad becom

3-25AUTO VOL (Automatic Volume): With automaticvolume, your audio system adjusts automatically tomake up for road and wind noise as you drive.Set the

3-26Setting Preset StationsThe six numbered pushbuttons let you return to your favorite stations. You can set up to 18 stations(six AM, six FM1 and si

3-27To return the bass and treble to the manual mode, press and release the AUDIO knob.If your vehicle has the Bose radio, your audio systemallows you

3-28Using RDSYour audio system is equipped with a Radio DataSystem (RDS). RDS is a system that sends data alongwith the audio of the FM station you ar

3-29DISP (Display): Press this knob to change what appearson the display while using RDS. Pressing this knob willalso display an RDS station frequency

3-30INFO (Information): If the current station has amessage, the information icon will appear on thedisplay. These text messages are from the RDSbroad

1-105. Turn the blue or yellow handle down until it is in theretaining clip.6. If the vehicle has a floor mat, put the flap back to its original posit

3-31Playing a Cassette TapeYour tape player is built to work best with tapes that areup to 30 to 45 minutes long on each side. Tapes longerthan that a

3-324 FWD (Forward): Press this pushbutton to advancequickly to another part of the tape. Press this pushbuttonagain to return to playing speed. The r

3-33Cassette Tape MessagesCHK TAPE (Check Tape): If CHK TAPE appears onthe radio display, the tape won’t play because of one ofthe following errors.Th

3-343 REV (Reverse): Press and hold this pushbutton toreverse quickly within a track. Press and hold thispushbutton for less than two seconds to rever

3-35Compact Disc MessagesIf the disc comes out, it could be for one of thefollowing reasons:If you’re driving on a very rough road. When theroad becom

3-36AUTO VOL (Automatic Volume): Your system has afeature called automatic volume. With this feature, youraudio system adjusts automatically to make u

3-37Setting Preset StationsThe six numbered pushbuttons let you return to your favorite stations. You can set up to 18 stations(six AM, six FM1 and si

3-38Adjusting the Speakers (Balance/Fade)AUDIO: To adjust the balance between the right andleft speakers, push the AUDIO knob until BAL appearson the

3-39Finding a PTY StationP-TYPE (Program Type): This button is used to turnon and off Program Type (PTY) selections. PTY and thelight next to the butt

3-40RDS MessagesALERT!: This type of announcement warns of nationalor local emergencies. You will not be able to turn offalert announcements. ALERT! a

1-11CAUTION:It is extremely dangerous to ride in a cargo area, inside or outside of a vehicle. In a collision,people riding in these areas are more li

3-41Playing a Compact DiscIf an error appears on the display, see “Compact DiscMessages” later in this section.LOAD CD : Press the LOAD side of this

3-42Playing a Specific Loaded Compact DiscFor every CD loaded, a number will appear on the radiodisplay. To play a specific CD, first press the CD AUX

3-43RPT (Repeat): With repeat, you can repeat one track oran entire disc. To use repeat, do the following:To repeat the track you are listening to, pr

3-44P-TYPE (Program Type): Press this knob to see howlong the current track has been playing. To change whatis normally shown on the display (track or

3-45To delete tracks from the song list, perform thefollowing steps:1. Turn the disc player on.2. Press the SONG LIST button to turn song list on.S-LI

3-46Compact Disc MessagesCHECK CD: If this message appears on the radiodisplay, it could be due to one of the following reasons:The road is too rough.

3-47Understanding Radio ReceptionAMThe range for most AM stations is greater than for FM,especially at night. The longer range, however, cancause stat

3-48Care of Your Cassette Tape PlayerA tape player that is not cleaned regularly can causereduced sound quality, ruined cassettes or a damagedmechanis

3-49If your vehicle is equipped with the AM-FM Stereo with Cassette Tape and Compact Disc Player with Radio Data System and Programmable Equalization

3-50Care of Your Compact DiscsHandle discs carefully. Store them in their original casesor other protective cases and away from direct sunlightand dus

1-12Why Safety Belts WorkWhen you ride in or on anything, you go as fast as it goes.Take the simplest vehicle. Suppose it’s just a seat on wheels.Put

4-4-1Section 4 Your Driving and the RoadHere you’ll find information about driving on different kinds of roads and in varying weather conditions. We’

4-2Defensive DrivingThe best advice anyone can give about driving is: Drive defensively.Please start with a very important safety device in yourvehicl

4-3Drunken DrivingDeath and injury associated with drinking and driving isa national tragedy. It’s the number one contributor to the highway death tol

4-4According to the American Medical Association, a180-lb. (82 kg) person who drinks three 12-ounce(355 ml) bottles of beer in an hour will end up wit

4-5But the ability to drive is affected well below a BAC of 0.10 percent. Research shows that the driving skills of many people are impaired at a BAC

4-6Control of a VehicleYou have three systems that make your vehicle go whereyou want it to go. They are the brakes, the steering andthe accelerator.

4-7Avoid needless heavy braking. Some people drive in spurts -- heavy acceleration followed by heavy braking -- rather than keeping pace with traffic.

4-8Let’s say the road is wet and you’re driving safely.Suddenly, an animal jumps out in front of you. You slam on the brakes and continue braking. Her

4-9Remember: Anti-lock doesn’t change the time you needto get your foot up to the brake pedal or always decreasestopping distance. If you get too clos

4-10The traction you can get in a curve depends on thecondition of your tires and the road surface, the angle at which the curve is banked, and your s

i2002 Chevrolet ExpressOwner’s ManualLitho in U.S.A. Copyright General Motors Corporation 2001Part Number C2214 A First Edition All Rights Reserved

1-13Get it up to speed. Then stop the vehicle. The riderdoesn’t stop.The person keeps going until stopped by something.In a real vehicle, it could be

4-11An emergency like this requires close attention and aquick decision. If you are holding the steering wheel atthe recommended 9 and 3 o’clock posit

4-12PassingThe driver of a vehicle about to pass another on atwo-lane highway waits for just the right moment,accelerates, moves around the vehicle ah

4-13Check your mirrors, glance over your shoulder andstart your left lane change signal before moving outof the right lane to pass. When you are far e

4-14If your vehicle starts to slide, ease your foot off theaccelerator pedal and quickly steer the way you want the vehicle to go. If you start steeri

4-15Here are some tips on night driving.Drive defensively.Don’t drink and drive.Adjust your inside rearview mirror to reduce theglare from headlamps b

4-16Driving in Rain and on Wet RoadsRain and wet roads can mean driving trouble. On a wetroad, you can’t stop, accelerate or turn as well becauseyour

4-17Driving too fast through large water puddles or evengoing through some car washes can cause problems, too.The water may affect your brakes. Try to

4-18Hydroplaning doesn’t happen often. But it can if yourtires do not have much tread or if the pressure in one ormore is low. It can happen if a lot

4-19City DrivingOne of the biggest problems with city streets is theamount of traffic on them. You’ll want to watch out forwhat the other drivers are

4-20Freeway DrivingMile for mile, freeways (also called thruways, parkways,expressways, turnpikes or superhighways) are the safestof all roads. But th

1-14or the instrument panel ... or the safety belts!With safety belts, you slow down as the vehicle does.You get more time to stop. You stop over more

4-21The exit speed is usually posted.Reduce your speed according to your speedometer, notto your sense of motion. After driving for any distanceat hig

4-22Highway HypnosisIs there actually such a condition as “highway hypnosis”?Or is it just plain falling asleep at the wheel? Call ithighway hypnosis,

4-23If you drive regularly in steep country, or if you’replanning to visit there, here are some tips that can makeyour trips safer and more enjoyable.

4-24Winter DrivingHere are some tips for winter driving:Have your vehicle in good shape for winter.You may want to put winter emergency supplies inyou

4-25What’s the worst time for this? “Wet ice.” Very coldsnow or ice can be slick and hard to drive on. But wetice can be even more trouble because it

4-26If You’re Caught in a BlizzardIf you are stopped by heavy snow, you could be in aserious situation. You should probably stay with yourvehicle unle

4-27CAUTION:Snow can trap exhaust gases under your vehicle.This can cause deadly CO (carbon monoxide) gasto get inside. CO could overcome you and kill

4-28Loading Your VehicleThe Certification/Tire label is found on the rear edge ofthe driver’s door. The label shows the size of youroriginal tires and

4-29CAUTION:Things you put inside your vehicle can strike and injure people in a sudden stop or turn, or in a crash.Put things in the cargo area of yo

4-30Trailering PackageIf your vehicle is equipped with the trailering package,there is also a load rating which includes the weight ofthe vehicle and

1-15Here Are Questions Many People AskAbout Safety Belts -- and the AnswersQ:Won’t I be trapped in the vehicle after anaccident if I’m wearing a safet

4-31NOTICE:Pulling a trailer improperly can damage yourvehicle and result in costly repairs not covered byyour warranty. To pull a trailer correctly,

4-32If You Do Decide To Pull A TrailerIf you do, here are some important points:There are many different laws, including speed limitrestrictions, havi

4-33Model Engine Axle Ratio Max. Trailer Weight (lbs.) (kg) GCWR (lbs.) (kg)G1500 (Cargo) 4.3L 3.42 4,600 (2088) 9,500 (4313)5.0L 3.42 5,600 (2542) 10

4-34Model Engine Axle Ratio Max. Trailer Weight (lbs.) (kg) GCWR (lbs.) (kg)G2500 (Passenger) 5.7L 3.73 5,800 (2633) 12,000 (5448)4.10 7,300 (3314) 13

4-35Maximum trailer weight is calculated assuming thedriver and one passenger are in the towing vehicle and it has all the required trailering equipme

4-36Total Weight on Your Vehicle’s TiresBe sure your vehicle’s tires are inflated to the upperlimit for cold tires. You’ll find these numbers on theCe

4-37Safety ChainsYou should always attach chains between your vehicleand your trailer. Cross the safety chains under the tongueof the trailer to help

4-38Driving with a TrailerCAUTION:If you have a rear-most window open and youpull a trailer with your vehicle, carbon monoxide(CO) could come into you

4-39Following DistanceStay at least twice as far behind the vehicle ahead as youwould when driving your vehicle without a trailer. Thiscan help you av

4-40Turn Signals When Towing a TrailerWhen you tow a trailer, your vehicle has to have extrawiring and a heavy-duty turn signal flasher (included inth

1-16How to Wear Safety Belts ProperlyAdultsThis part is only for people of adult size.Be aware that there are special things to know about safety bel

4-41Parking on HillsCAUTION:You really should not park your vehicle, with atrailer attached, on a hill. If something goeswrong, your rig could start t

4-42Trailer Wiring HarnessThe optional heavy-duty trailer wiring package is aseven-wire harness assembly. The four-wire portion ofthe harness assembly

5-5-1Section 5 Problems on the RoadHere you’ll find what to do about some problems that can occur on the road.5-2 Hazard Warning Flashers5-2 Other War

5-2Hazard Warning FlashersYour hazard warning flashers let you warn others. Theyalso let police know you have a problem. Your front andrear turn signa

5-3Jump StartingIf your battery has run down, you may want to useanother vehicle and some jumper cables to start yourvehicle. Be sure to follow the st

5-41. Check the other vehicle. It must have a 12-voltbattery with a negative ground system.NOTICE:If the other system isn’t a 12-volt system with aneg

5-54. Open the hoods and locate the batteries. Find thepositive (+) and negative (-) terminal locations oneach vehicle. You should always use the remo

5-6CAUTION:Fans or other moving engine parts can injure youbadly. Keep your hands away from moving partsonce the engine is running.5. Check that the j

5-77. Don’t let the other endtouch metal. Connect itto the positive (+)terminal of the goodbattery. Use a remotepositive (+) terminal ifthe vehicle ha

5-89. Connect the other end of the negative (-) cable tothe remote negative (-) jump starting terminal.Remove the cap before using it.10. Now start th

1-175. To make the lap part tight, pull down on the buckleend of the belt as you pull up on the shoulder belt.The lap part of the belt should be worn

5-9 Jumper Cable RemovalA. Heavy, Unpainted Metal Engine Part or RemoteNegative (-) TerminalB. Good Battery or Remote Positive (+) and RemoteNegative

5-10Engine Overheating (Gasoline Engine)You will find a coolant temperature gage on yourvehicle’s instrument panel. If you have a diesel engine, you w

5-11CAUTION:Steam from an overheated engine can burn youbadly, even if you just open the hood. Stay awayfrom the engine if you see or hear steam comin

5-12If you get the overheat warning with no sign of steam,try this for a minute or so:1. If you have an air conditioner and it’s on, turn it off.2. Tu

5-13When the engine is cold, the coolant level should be ator above the FULL COLD mark. If it isn’t, you mayhave a leak at the pressure cap or in the

5-14NOTICE:When adding coolant, it is important that you use only DEX-COOL (silicate-free) coolant.If coolant other than DEX-COOL is added to the sys

5-15NOTICE:In cold weather, water can freeze and crack theengine, radiator, heater core and other parts. Use the recommended coolant and the propercoo

5-16CAUTION:Steam and scalding liquids from a hot coolingsystem can blow out and burn you badly. Theyare under pressure, and if you turn the radiatorp

5-17How to Add Coolant to the Radiator1. You can remove the radiator pressure cap when thecooling system, including the radiator pressure capand upper

5-183. Fill the radiator with the proper DEX-COOLcoolant mixture, up to the base of the filler neck. See“Engine Coolant” in the Index for more informa

1-18Shoulder Belt Height AdjusterBefore you begin to drive, move the shoulder beltadjuster to the height that is right for you.To move it down, push i

5-196. Start the engine and let it run until you can feel theupper radiator hose getting hot. Watch out for theengine cooling fan.7. By this time, the

5-20Engine Fan NoiseYour vehicle has a clutched engine cooling fan. Whenthe clutch is engaged, the fan spins faster to providemore air to cool the eng

5-21Changing a Flat TireIf a tire goes flat, avoid further tire and wheel damageby driving slowly to a level place. Turn on your hazardwarning flasher

5-22Removing the Spare Tire and ToolsYour spare tire is stored underneath the rear of yourvehicle. You will use the ratchet and extension to lowerthe

5-23For cargo vans, and allpassenger vans except thosewith the 15-passengerseating arrangement, thejack is secured in the rearpassenger side corner of

5-24The ratchet has a DOWN side and an UP side.Attach the ratchet, with the DOWN side facing you, tothe extension. The extension has a socket end and

5-25When the tire has been lowered, tilt the retainer at theend of the cable and pull it through the wheel opening.NOTICE:To help avoid vehicle damage

5-26The tools you’ll be using include the jack (A), jackhandle extension (B), jack handle (C), socket (D) andthe ratchet (E).Removing the Wheel Covers

5-272. Loosen the plastic nut caps. 3. Remove the center cap.

5-28Removing the Flat Tire and Installing theSpare Tire1. With the DOWN side facing you, use the ratchet andsocket to loosen all the wheel nuts. Don’t

1-19Q: What’s wrong with this?A: The shoulder belt is too loose. It won’t give nearlyas much protection this way.CAUTION:You can be seriously hurt if

5-29Front Position4. Position jack under the vehicle as shown. Rear PositionCAUTION:Getting under a vehicle when it is jacked up isdangerous. If the v

5-30CAUTION:Raising your vehicle with the jack improperlypositioned can damage the vehicle and even make the vehicle fall. To help avoid personalinjur

5-316. Remove all the wheelnuts, and take off the flat tire.7. Remove any rust or dirtfrom the wheel bolts,mounting surfaces andspare wheel.CAUTION:Ru

5-328. Put the wheel nuts backon with the rounded endof the nuts toward thewheel. Tighten eachwheel nut by hand untilthe wheel is held againstthe hub.

5-3311. Put the wheel cover back on, or put the center capand plastic wheel nut caps back on. Remove anywheel blocks.Remember that the jack, jacking e

5-343. Pull the wheel toward the rear of the vehicle,keeping the cable tight.4. Attach the ratchet, with the UP side facing you, tothe extension.

5-355. Put the flat end of the extension on an angle throughthe hole in the rear door frame, above the bumper.6. Raise the tire fully against the unde

5-36If You’re Stuck: In Sand, Mud, Ice or SnowIn order to free your vehicle when it is stuck, you willneed to spin the wheels, but you don’t want to s

6-6-1Section 6 Service and Appearance CareHere you will find information about the care of your vehicle. This section begins with service and fuel inf

6-2ServiceYour dealer knows your vehicle best and wants you tobe happy with it. We hope you’ll go to your dealer forall your service needs. You’ll get

1-20Q: What’s wrong with this?A: The belt is buckled in the wrong place.CAUTION:You can be seriously injured if your belt is buckledin the wrong place

6-3CAUTION:You can be injured and your vehicle could bedamaged if you try to do service work on avehicle without knowing enough about it.Be sure you h

6-4In Canada, look for the “Auto Makers’Choice” label on the pump.Canada OnlyCalifornia FuelIf your vehicle is certified to meet California EmissionSt

6-5NOTICE:Your vehicle was not designed for fuel thatcontains methanol. Don’t use fuel containingmethanol. It can corrode metal parts in your fuel sys

6-6The fuel cap is behind ahinged door on the driver’sside of your vehicle.While refueling yourvehicle, hang the fuel capby the tether from the hookon

6-7When you put the fuel cap back on, turn it to the right(clockwise) until you hear a clicking sound. Make sureyou fully install the cap. The diagnos

6-8Checking Things Under the HoodCAUTION:If your vehicle has air conditioning, the auxiliaryengine fan under the hood can start up andinjure you even

6-92. Then go to the front of the vehicle and release thesecondary hood release.3. Lift the hood.4. Release the hood propfrom its retainer and putthe

6-10Engine Compartment OverviewWhen you lift the hood, you’ll see these items:A. BatteryB. Coolant Recovery TankC. Engine Oil DipstickD. Engine Oil Fi

6-11Before closing the hood, be sure all the filler caps are on properly.Then lift the hood to relieve pressure on the hood prop.Remove the hood prop

6-12Engine:Removal or rendering engine speed governor (if equipped) inoperative so as to allow engine speed to exceed manufacturer specifications.Fan

1-21Q: What’s wrong with this?A: The belt is over an armrest.CAUTION:You can be seriously injured if your belt goesover an armrest like this. The belt

6-13Pull out the dipstick and clean it with a paper towel orcloth, then push it back in all the way. Remove it again,keeping the tip down, and check t

6-14What Kind of Engine Oil to UseOils recommended for your vehicle can be identified bylooking for the starburst symbol.This symbol indicates that th

6-15As in the chart shown previously, SAE 5W-30 is best foryour vehicle. However, you can use SAE 10W-30 if it’sgoing to be 0 F (-18 C) or above. Thes

6-16When to Change Engine OilIf any one of these is true for you, use the short trip/citymaintenance schedule:Most trips are less than 5 miles (8 km).

6-17Engine Air Cleaner/Filter (Gasoline Engines)The engine air cleaner/filter is located near the center ofthe engine compartment. See “Engine Compart

6-18To change the engine air cleaner/filter, do the following:1. Unhook the retainer clips and remove the cover.2. Lift the filter out of the engine a

6-19Automatic Transmission FluidIf your vehicle has a diesel engine, see “AutomaticTransmission Fluid” in the Diesel Supplement.When to Check and Chan

6-20To get the right reading, the fluid should be at normal operating temperature, which is 180 F to 200 F (82 C to 93 C).Get the vehicle warmed up by

6-21Then, without shutting off the engine, follow these steps:The transmission dipstick has a red handle and is locatednear the center of the engine c

6-22How to Add FluidRefer to the Maintenance Schedule to determine whatkind of transmission fluid to use. See “RecommendedFluids and Lubricants” in th

1-22Q: What’s wrong with this?A: The shoulder belt is worn under the arm. It shouldbe worn over the shoulder at all times.CAUTION:You can be seriously

6-23Rear AxleWhen to Check LubricantRefer to the Maintenance Schedule to determine howoften to check the lubricant. See “ScheduledMaintenance Services

6-24A 50/50 mixture of clean, drinkable water andDEX-COOL coolant will:Give freezing protection down to -34 F (-37 C).Give boiling protection up to 2

6-25NOTICE:If you use an improper coolant mixture, yourengine could overheat and be badly damaged.The repair cost wouldn’t be covered by yourwarranty.

6-26Adding CoolantIf you need more coolant, add the proper DEX-COOLcoolant mixture at the coolant recovery tank.CAUTION:Turning the radiator pressure

6-27Radiator Pressure CapThe radiator pressure cap islocated near the center ofthe engine compartment.NOTICE:Your radiator cap is a pressure-type cap

6-28When to Check Power Steering FluidIt is not necessary to regularly check power steeringfluid unless you suspect there is a leak in the system oryo

6-29NOTICE:When using concentrated washer fluid,follow the manufacturer’s instructions foradding water.Don’t mix water with ready-to-use washerfluid.

6-30The other reason is that fluid is leaking out of the brakesystem. If it is, you should have your brake system fixed,since a leak means that sooner

6-31What to AddWhen you do need brake fluid, use only DOT-3 brakefluid. Refer to “Recommended Fluids and Lubricants”in the Index. Use new brake fluid

6-32Brake WearYour vehicle has front disc brakes and rear drum brakes.Disc brake pads have built-in wear indicators that make a high-pitched warning s

iiGENERAL MOTORS, GM, the GM Emblem,CHEVROLET, the CHEVROLET Emblem and thename CHEVY EXPRESS are registered trademarks of General Motors Corporation.

1-23Q: What’s wrong with this?A: The belt is twisted across the body.CAUTION:You can be seriously injured by a twisted belt. In a crash, you wouldn’t

6-33Brake Pedal TravelSee your dealer if the brake pedal does not return tonormal height, or if there is a rapid increase in pedaltravel. This could b

6-34Vehicle StorageIf you’re not going to drive your vehicle for 25 days or more, remove the black, negative (-) cable from the battery. This will hel

6-35Sealed Beam Headlamp1. Remove the four screws from the headlamp retainer.Pull the retainer out and set it aside.2. Unplug the lamp assembly from t

6-364. Reinstall the new bulb into the socket and return it tothe headlamp assembly.Front Parking/Turn Signal LampsTo replace the front parking/turn s

6-372. Remove the lamp from the grille.3. Squeeze the tab on the side of the bulb assemblywhile turning it counterclockwise.4. Remove the bulb assembl

6-382. Unclip the bottom of the lamp from the grille.3. Pull the bulb straight out to remove it. Install the new bulb.4. Reverse these steps to reinst

6-393. Remove the nuts with a deep socket wrench. 4. Remove the hidden upper nuts.

6-405. Lift the lamp as you turn it toward the rear of the vehicle.6. To remove, squeeze the tab on the side of the socketswhile turning them counterc

6-417. Turn the old bulb counterclockwise to remove it.Install the new bulb.8. Reverse the above steps to reinstall the lamp.Windshield Wiper Blade Re

6-422. Press down on the blade assembly pivot locking tab.Pull down on the blade assembly to release it fromthe wiper arm hook.3. The insert has two n

1-24To unlatch the belt, just push the button on the buckle.The belt should go back out of the way.Before you close the door, be sure the belt is out

6-43Inflation -- Tire PressureThe Certification/Tire label, which is on the rear edge ofthe driver’s door, shows the correct inflation pressuresfor yo

6-44How to CheckUse a good quality pocket-type gage to check tirepressure. You can’t tell if your tires are properly inflatedsimply by looking at them

6-45If your vehicle has dual rear wheels, always use one ofthe correct rotation patterns shown here when rotatingyour tires.When you install dual whee

6-46When It’s Time for New TiresOne way to tell when it’stime for new tires is tocheck the treadwearindicators, which willappear when your tires haveo

6-47Buying New TiresTo find out what kind and size of tires you need, look atthe Certification/Tire label.The tires installed on your vehicle when it

6-48Uniform Tire Quality GradingQuality grades can be found where applicable on the tiresidewall between tread shoulder and maximum sectionwidth. For

6-49Temperature -- A, B, CThe temperature grades are A (the highest), B, and C,representing the tire’s resistance to the generation ofheat and its abi

6-50Wheel ReplacementReplace any wheel that is bent, cracked, or badly rustedor corroded. If wheel nuts keep coming loose, the wheel,wheel bolts and w

6-51Whenever a wheel, wheel bolt or wheel nut is replacedon a dual wheel setup, check the wheel nut torque after100, 1,000 and 6,000 miles (160, 1 600

6-52Appearance CareRemember, cleaning products can be hazardous. Someare toxic. Others can burst into flame if you strike amatch or get them on a hot

1-25The best way to protect the fetus is to protect the mother. When a safety belt is worn properly, it’s more likely that the fetus won’t be hurt in

6-53Here are some cleaning tips:Always read the instructions on the cleaner label.Clean up stains as soon as you can -- before they set.Carefully scra

6-54Cleaning VinylUse warm water and a clean cloth.Rub with a clean, damp cloth to remove dirt. Youmay have to do it more than once.Things like tar, a

6-55Cleaning Glass SurfacesGlass should be cleaned often. GM Glass Cleaner or aliquid household glass cleaner will remove normaltobacco smoke and dust

6-56Cleaning the Outside of Your VehicleThe paint finish on your vehicle provides beauty, depthof color, gloss retention and durability.Washing Your V

6-57Foreign materials such as calcium chloride and othersalts, ice melting agents, road oil and tar, tree sap, birddroppings, chemicals from industria

6-58Cleaning TiresTo clean your tires, use a stiff brush with a tire cleaner.NOTICE:When applying a tire dressing always take care towipe off any over

6-59Underbody MaintenanceChemicals used for ice and snow removal and dustcontrol can collect on the underbody. If these are notremoved, accelerated co

6-60GM Vehicle Care/Appearance Materials

6-61Vehicle Identification Number (VIN)This is the legal identifier for your vehicle. It appears ona plate in the front corner of the instrument panel

6-62Electrical SystemAdd-On Electrical EquipmentNOTICE:Don’t add anything electrical to your vehicleunless you check with your dealer first. Someelect

1-26If it says AIR BAG on the middle part of the steeringwheel and AIR BAG on the instrument panel in front ofthe right front passenger’s seat, your v

6-63Instrument Panel Fuse BlockThe fuse block access dooris on the instrument panelabove the hood release lever on the driver’s side of the vehicle.Yo

6-64POSITION NAME CIRCUITS PROTECTED1. STOP Center High Mounted Stop Lamp, Stoplamps2. HTD MIR Electric Heated Mirrors3. CTSY Courtesy Lamps, Dome/RDG

6-65POSITION NAME CIRCUITS PROTECTED14. ILLUM Instrument Panel Cluster, HVAC Controls, RR HVAC Controls,Instrument Panel Switches, Radio Illumination,

6-66Engine Compartment Fuse BlockThe fuse block is in the engine compartment on thedriver’s side of the vehicle.NAME CIRCUITS PROTECTEDSPARE Spare Fus

6-67NAME CIRCUITS PROTECTEDETC Electronic Throttle ControlRR BLOWER Rear Auxiliary Blower Motor RelaysCNG Compressed Natural GasENG-I Heated O2 Sensor

6-68Replacement BulbsLAMP OR BULB QTY NUMBERSealed Beam Headlamps 2 H6054Composite Low-Beam Headlamps2 6052Composite High-Beam Headlamps2 9005Front Si

6-69Capacities and SpecificationsAll capacities are approximate. When adding, be sure to fill to the appropriate level or as recommended in this manua

6-70Wheel Nut TorqueMODEL TORQUEAll140 lb-ft (190 N·m)Cooling System CapacityENGINE VIN QTY Without Rear Heater QTY With Rear Heater“VORTEC” 4300 V6

6-71Fuel Tank CapacityTYPE QUANTITY MODEL TYPEStandard Tank 31.0 U.S. gallons (117.3 L) Passenger and CargoStandard Tank 35.0 U.S. gallons (132.5 L) C

6-72Normal Maintenance Replacement PartsReplacement PartsReplacement part numbers listed in this section are based on the latest information available

1-27Here are the most important things to know about the air bag system:CAUTION:You can be severely injured or killed in a crash ifyou aren’t wearing

7-7-1Section 7 Maintenance ScheduleThis section covers the maintenance required for your vehicle. Your vehicle needs these services to retain its safe

7-2Have you purchased the GM Protection Plan? The Plansupplements your new vehicle warranties. See yourWarranty and Owner Assistance booklet or your d

7-3How This Section is OrganizedThis maintenance schedule is divided into five parts:“Part A: Scheduled Maintenance Services” explainswhat to have don

7-4Part A: Scheduled Maintenance ServicesUsing Your Maintenance ScheduleWe at General Motors want to help you keep yourvehicle in good working conditi

Scheduled Maintenance7-5Short Trip/City DefinitionFollow the Short Trip/City Scheduled Maintenance ifany one of these conditions is true for your vehi

Scheduled Maintenance7-6Short Trip/City IntervalsEvery 24,000 Miles (40 000 km): Diesel Engine Only:Fuel Cap Replacement, if driving in dusty conditio

Scheduled Maintenance7-7Long Trip/Highway DefinitionFollow this scheduled maintenance only if none of the conditions from the Short Trip/City Schedule

Scheduled Maintenance7-8Long Trip/Highway IntervalsEvery 30,000 Miles (50 000 km): Fuel FilterReplacement. Diesel Engine Only: Engine AirCleaner Filte

Short Trip/City Scheduled Maintenance7-9The services shown in this schedule up to 100,000 miles(166 000 km) should be repeated after 100,000 miles(166

Short Trip/City Scheduled Maintenance7-103,000 Miles (5 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission C

1-28If your vehicle has an air bag for the right frontpassenger, please read this:CAUTION:Anyone who is up against, or very close to, anyair bag when

Short Trip/City Scheduled Maintenance7-119,000 Miles (15 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-1215,000 Miles (25 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-13Diesel Engine Only: Check the air intake system installation to assure thatgaskets are properly sealed and th

Short Trip/City Scheduled Maintenance7-1421,000 Miles (35 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-1527,000 Miles (45 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-1630,000 Miles (50 000 km) (Continued)Diesel Engine Only: Replace engine air cleaner filter. An Emission Contro

Short Trip/City Scheduled Maintenance7-1733,000 Miles (55 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-1842,000 Miles (70 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

Short Trip/City Scheduled Maintenance7-19Clean and repack the front wheel bearings (or at each brake relining,whichever occurs first).Diesel Engine On

Short Trip/City Scheduled Maintenance7-2048,000 Miles (80 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emission

1-29How the Air Bag System WorksWhere are the air bags?The driver’s air bag is in the middle of the steering wheel.The right front passenger’s air bag

Short Trip/City Scheduled Maintenance7-2151,000 Miles (85 000 km)Change engine oil and filter (or every 3 months, whichever occurs first).An Emission

Short Trip/City Scheduled Maintenance7-2260,000 Miles (100 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-23Gasoline Engine Only: Conduct evaporative control system inspection. Checkall fuel and vapor lines and hoses

Short Trip/City Scheduled Maintenance7-2463,000 Miles (105 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-2572,000 Miles (120 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-2675,000 Miles (125 000 km) (Continued)Diesel Engine Only: Inspect engine air cleaner filter if you are driving

Short Trip/City Scheduled Maintenance7-2778,000 Miles (130 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-2884,000 Miles (140 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-2990,000 Miles (150 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-3090,000 Miles (150 000 km) (Continued)Vehicles With GVWR Above 10,000 lbs. or Equipped with Diesel EngineOnly:

1-30CAUTION:If something is between an occupant and an airbag, the bag might not inflate properly or it mightforce the object into that person causing

Short Trip/City Scheduled Maintenance7-3196,000 Miles (160 000 km)Change engine oil and filter (or every 3 months, whichever occurs first). An Emissio

Short Trip/City Scheduled Maintenance7-32100,000 Miles (166 000 km)Gasoline Engine Only: Inspect spark plug wires. An Emission Control Service.Gasolin

Long Trip/Highway Scheduled Maintenance7-33The services shown in this schedule up to 100,000 miles(166 000 km) should be repeated after 100,000 miles(

Long Trip/Highway Scheduled Maintenance7-347,500 Miles (12 500 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emissi

Long Trip/Highway Scheduled Maintenance7-35Rotate tires. See “Tire Inspection and Rotation” in the Index for properrotation pattern and additional inf

Long Trip/Highway Scheduled Maintenance7-3630,000 Miles (50 000 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emiss

Long Trip/Highway Scheduled Maintenance7-37Diesel Engine Only: Check the air intake system installation to assure thatgaskets are properly sealed and

Long Trip/Highway Scheduled Maintenance7-3845,000 Miles (75 000 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emiss

Long Trip/Highway Scheduled Maintenance7-3950,000 Miles (83 000 km)Change automatic transmission fluid and filter if the vehicle has a dieselengine, i

Long Trip/Highway Scheduled Maintenance7-4060,000 Miles (100 000 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emis

1-31What makes an air bag inflate?In an impact of sufficient severity, the air bag sensingsystem detects that the vehicle is in a crash. The sensingsy

Long Trip/Highway Scheduled Maintenance7-41Gasoline Engine Only: Inspect Evaporative Control System. Check all fueland vapor lines and hoses for prope

Long Trip/Highway Scheduled Maintenance7-4267,500 Miles (112 500 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emis

Long Trip/Highway Scheduled Maintenance7-43Diesel Engine Only: Check the air intake system installation to assure thatgaskets are properly sealed and

Long Trip/Highway Scheduled Maintenance7-4490,000 Miles (150 000 km)Change engine oil and filter (or every 12 months, whichever occurs first). An Emis

Long Trip/Highway Scheduled Maintenance7-45Diesel Engine Only: Check the air intake system installation to assure thatgaskets are properly sealed and

Long Trip/Highway Scheduled Maintenance7-46100,000 Miles (166 000 km)Gasoline Engine Only: Inspect spark plug wires. An Emission Control Service. Gaso

Long Trip/Highway Scheduled Maintenance7-47150,000 Miles (240 000 km)Drain, flush and refill cooling system (or every 60 months since last service,whi

7-48Part B: Owner Checks and ServicesListed in this part are owner checks and services whichshould be performed at the intervals specified to helpensu

7-49At Least Twice a YearRestraint System CheckMake sure the safety belt reminder light and all yourbelts, buckles, latch plates, retractors and ancho

7-50Weatherstrip LubricationSilicone grease on weatherstrips will make them lastlonger, seal better, and not stick or squeak. Applysilicone grease wit

1-32Air bags are designed to inflate only once. After theyinflate, you’ll need some new parts for your air bagsystem. If you don’t get them, the air b

7-51Starter Switch CheckCAUTION:When you are doing this check, the vehicle couldmove suddenly. If it does, you or others could beinjured. Follow the s

7-52Ignition Transmission Lock CheckWhile parked, and with the parking brake set, try to turnthe ignition key to LOCK in each shift lever position.The

7-53Part C: Periodic Maintenance InspectionsListed in this part are inspections and services whichshould be performed at least twice a year (for insta

7-54Fuel System InspectionInspect the complete fuel system for damage or leaks.Engine Cooling System InspectionInspect the hoses and have them replace

7-55Part D: Recommended Fluids and LubricantsFluids and lubricants identified below by name, partnumber or specification may be obtained from your dea

7-56USAGE FLUID/LUBRICANTHydraulic Brake SystemDelco Supreme 11 Brake Fluid(GM Part No. 12377967 orequivalent DOT-3 brake fluid).WindshieldWasher Sol

7-57USAGE FLUID/LUBRICANTRear Axle (2500 and3500 Series with LockingDifferential Only)Axle Lubricant; use only GMPart No. 1052271. Do not addfriction

7-58Part E: Maintenance RecordAfter the scheduled services are performed, record the date, odometer reading and who performed the service in theboxes

7-59Maintenance RecordDATEODOMETERREADINGSERVICED BY MAINTENANCE PERFORMED

7-60Maintenance RecordDATEODOMETERREADINGSERVICED BY MAINTENANCE PERFORMED

iiiHow to Use this ManualMany people read their owner’s manual from beginningto end when they first receive their new vehicle. If youdo this, it will

1-33Servicing Your Air Bag-Equipped VehicleAir bags affect how your vehicle should be serviced.There are parts of the air bag system in several places

8-8-1Section 8 Customer Assistance InformationHere you will find out how to contact Chevrolet if you need assistance. This section also tells you how

8-2Customer Satisfaction ProcedureYour satisfaction and goodwill are important to yourdealer and to Chevrolet. Normally, any concerns withthe sales tr

8-3STEP TWO -- If after contacting a member of dealership management, it appears your concern cannot be resolved by the dealership without further hel

8-4You may contact the BBB using the toll-free telephonenumber or write them at the following address:BBB Auto LineCouncil of Better Business Bureaus,

8-5CanadaGeneral Motors of Canada LimitedCustomer Communication Centre, 163-0051908 Colonel Sam DriveOshawa, Ontario L1H 8P71-800-263-3777 (English)1-

8-6Chevrolet Roadside Assistance ProgramTo enhance Chevrolet’s strong commitment to customersatisfaction, Chevrolet is excited to announce theestablis

8-7Roadside Courtesy Care provides:Roadside Basic Care services (as outlined previously)Plus:FREE Non-Warranty Towing (to the closest dealerfrom a leg

8-8For prompt assistance when calling, please have thefollowing available to give to the advisor:Vehicle Identification Number (VIN)License plate numb

8-9If the dealer requests that you simply drop the vehicleoff for service, you are urged to do so as early in thework day as possible to allow for sam

8-10Courtesy Transportation is available only atparticipating dealers and all program options, such asshuttle service, may not be available at every d

1-34Rear Seat PassengersIt’s very important for rear seat passengers to buckle up!Accident statistics show that unbelted people in the rearseat are hu

8-11REPORTING SAFETY DEFECTS TO THE CANADIAN GOVERNMENTIf you live in Canada, and you believe that your vehiclehas a safety defect, you should immedia

8-12SERVICE PUBLICATIONS ORDERING INFORMATIONService ManualsService Manuals have the diagnosis and repairinformation on engines, transmission, axle, s

1-35When the shoulder belt is pulled out all the way, it will lock. If it does, let it go back all the way and start again.If the belt is not long eno

1-36CAUTION:You can be seriously hurt if your shoulder belt istoo loose. In a crash, you would move forward toomuch, which could increase injury. The

1-371. Locate the guide on the side of the seatback. 2. Slide the guide under and past the belt. The elasticcord must be under the belt. Then, place t

1-383. Be sure the elastic cord is not wrapped around theretainer pin as this decreases the length.4. Buckle, position and release the safety belt asd

1-39Center Passenger PositionLap BeltIf your vehicle has rear bench seats, someone can sit inthe center positions.When you sit in a center seating pos

1-40To make the belt shorter, pull its free end as shown untilthe belt is snug.Buckle, position and release it the same way as the lappart of a lap-sh

1-41CAUTION:People should never hold a baby in their armswhile riding in a vehicle. A baby doesn’t weighmuch -- until a crash. During a crash a baby w

1-42CAUTION:Children who are up against, or very close to, any air bag when it inflates can be seriouslyinjured or killed. Air bags plus lap-shoulder

ivVehicle Damage WarningsAlso, in this book you will find these notices:NOTICE:These mean there is something that could damageyour vehicle.In the noti

1-43CAUTION:The body structure of a young child is quiteunlike that of an adult or older child, for whomthe safety belts are designed. A young child’s

1-44CAUTION:Newborn infants need complete support, includingsupport for the head and neck. This is necessarybecause a newborn infant’s neck is weak an

1-45CAUTION:People should never hold a baby in their armswhile riding in a vehicle. A baby doesn’t weighmuch -- until a crash. During a crash a baby w

1-46Restraint Systems for ChildrenAn infant car bed (A), a special bed made for use in amotor vehicle, is an infant restraint system designed torestra

1-47A forward-facing child seat (C-E) provides restraint forthe child’s body with the harness and also sometimeswith surfaces such as T-shaped or shel

1-48Q: How do child restraints work?A: A child restraint system is any device designed foruse in a motor vehicle to restrain, seat, or positionchildre

1-49Where to Put the Restraint (Except CargoVans and Cab and Chassis Models)Accident statistics show that children are safer if theyare restrained in

1-50Where to Put the Restraint (Cargo Vansand Cab and Chassis Models)The child restraint must be secured properly in thepassenger seat. If your vehicl

1-51In Canada, the law requires that forward-facing child restraints have a top strap, and that the strap beanchored. In the United States, some child

1-52If your vehicle is a cargo van, the anchor for a top strapis located at the rear of the seat cushion on the rightfront passenger’s seat.Cargo Van

v

1-53Securing a Child Restraint in a RearOutside Seat PositionYou’ll be using the lap-shoulder belt. See the earlier part about the top strap if the ch

1-543. Buckle the belt. Make sure the release button ispositioned so you would be able to unbuckle thesafety belt quickly if you ever had to.4. Pull t

1-555. To tighten the belt, feed the shoulder belt back into the retractor while you push down on the childrestraint. If you’re using a forward-facing

1-56Securing a Child Restraint in a CenterSeat PositionYou’ll be using the lap belt. Be sure to follow the instructions that came with the child restr

1-574. Buckle the belt. Make sure the release button ispositioned so you would be able to unbuckle thesafety belt quickly if you ever had to.5. To tig

1-58Securing a Child Restraint in the RightFront Seat PositionIf your vehicle has a front passenger air bag, never put arear-facing child restraint in

1-59You’ll be using the lap-shoulder belt. See the earlier part about the top strap if the child restraint has one. Be sure to follow the instructions

1-605. Pull the rest of the shoulder belt all the way out ofthe retractor to set the lock.6. To tighten the belt, feed the shoulder belt back into the

1-61Older ChildrenOlder children who have outgrown booster seats shouldwear the vehicle’s safety belts.If you have the choice, a child should sit next

1-62CAUTION:Never do this.Here two children are wearing the same belt. The belt can’t properly spread the impact forces.In a crash, the two children c

viModel ReferenceThis manual covers these models:Passenger VanCargo VanCab and Chassis

1-63CAUTION:Never do this.Here a child is sitting in a seat that has alap-shoulder belt, but the shoulder part is behindthe child. If the child wears

1-64Safety Belt ExtenderIf the vehicle’s safety belt will fasten around you, you should use it.But if a safety belt isn’t long enough to fasten, yourd

2-2-1Section 2 Features and ControlsHere you can learn about the many standard and optional features on your vehicle, and information on starting,shif

2-2WindowsCAUTION:Leaving children in a vehicle with the windowsclosed is dangerous. A child can be overcome by the extreme heat and can suffer perman

2-3Power Windows (Option)If you have power windows, the controls are located oneach of the side doors.The driver’s door has a switch for the passenger

2-4Swing-Out WindowsSide Swing-Out WindowTo open the side door swing-out windows, pull up onthe latch at the edge of the window. Swing the windowout a

2-5Your vehicle has onedouble-sided key for theignition and all door locks.If you ever lose your key, your dealer will be able toassist you with obtai

2-6Door LocksCAUTION:Unlocked doors can be dangerous.Passengers -- especially children -- can easilyopen the doors and fall out of a movingvehicle. Wh

2-7Power Door Locks (Option)Press the bottom side of thepower door lock switch tolock all the doors at once.Press the top side of thepower door lock s

2-8Move the button to the left to engage the security feature. Move the button to the right to return the door locks tonormal operation.60/40 Swing-Ou

1-1-1Section 1 Seats and Restraint SystemsHere you’ll find information about the seats in your vehicle and how to use your safety belts properly. You

2-9Changes or modifications to this system by other than an authorized service facility could void authorization to use this equipment.At times you ma

2-10Matching Transmitter(s) to Your VehicleEach remote keyless entry transmitter is coded toprevent another transmitter from unlocking your vehicle.If

2-113. Align the covers and snap them together.4. Check the operation of the transmitter. If thetransmitter does not work after battery replacement,it

2-12Sliding Side Door (Option)To open the sliding side door from outside, pull thehandle toward the rear of the vehicle. Then, slide thedoor open.To c

2-13To open the sliding door from inside, turn the handleupward and toward the rear of the vehicle. Then, slidethe door toward the rear of the vehicle

2-1460/40 Swing-Out Side DoorTo open the front portion of a 60/40 door from theoutside, pull up on the handle and pull the handle toward you.To open t

2-15To open the rear portion of a 60/40 door from theoutside, pull the handle on the side of the rear door andpull it toward you.To close the 60/40 si

2-16Rear DoorsCAUTION:It can be dangerous to drive with the rear door(s)or rear swing-out windows open because carbonmonoxide (CO) gas can come into y

2-17To open the rear doors from the outside, pull the handletoward you to open the passenger’s side rear door first.To open the driver’s side rear doo

2-18Rear Swing-Out WindowThe rear swing-out windows work the same way as theside swing out windows, but the latch is located at thebottom edge of the

1-2Seats and Seat ControlsThis part tells you about the seats -- how to adjust them,take them out and put them back in. It also tells youabout reclini

2-19Parking at NightPark in a lighted spot, close all windows and lock yourvehicle. Remember to keep your valuables out of sight.Put them in a storage

2-20New Vehicle “Break-In”NOTICE:Your vehicle doesn’t need an elaborate “break-in.”But it will perform better in the long run if youfollow these guide

2-21NOTICE:If your key seems stuck in LOCK and you can’tturn it, be sure you are using the correct key; if so, is it all the way in? If it is, then tu

2-22NOTICE:Holding your key in START for longer than15 seconds at a time will cause your battery to be drained much sooner. And the excessive heatcan

2-23Engine Coolant Heater (If Equipped)In very cold weather, 0 F (-18 C) or colder, the enginecoolant heater can help. You’ll get easier starting andb

2-24How long should you keep the coolant heater pluggedin? The answer depends on the outside temperature, thekind of oil you have, and some other thin

2-25Ensure the shift lever is fully in PARK (P) beforestarting the engine. Your vehicle has an automatictransmission shift lock control system. With t

2-26DRIVE (D): This position is for normal driving. If you need more power for passing, and you’re:Going less than about 35 mph (55 km/h), push your a

2-27Parking BrakeTo set the parking brake, hold the regular brake pedaldown with your right foot. Push down the parking brakepedal with your left foot

2-28Shifting Into PARK (P)CAUTION:It can be dangerous to get out of your vehicle ifthe shift lever is not fully in PARK (P) with theparking brake firm